Native proteolytic enzymes in good quality normal bovine milk readily hydrolyscd the caseins during incubation or storage, producing the γ-caseins, proteosc-peptone components 5 (PP5) and 8-fast (PP8F) and a considerable number of other unidentified fragments, many of which were also subsequently found in the proteose-pcptone fraction. The rate of casein hydrolysis was greater in pasteurized than in raw milk, with β-casein being slightly more susceptible to attack than αs1-easein. Measurements of γ-cascin and proteose-peptone formation have been made and it was found that PP5 was an intermediate product that was subject to further proteolysis while PP8F was a stable end-product. With the exception of component 3 (PP3), virtually all constituents of the proteose-peptone fraction increased during storage and appeared to be products of the action of proteolytic enzymes. Further evidence was obtained from the effects of various inhibitors that the principal proteinase of normal milk is plasmin, but slight differences were apparent between the protein breakdown patterns induced by storage and by added plasmin, which was consistent with the presence of more than one proteinase. Incubations in the presence of soya bean trypsin inhibitor to prevent plasmin action clearly revealed that another enzyme(s) was also involved.

Details are given of a semi-micro Kjeldahl method for the determination of the total, casein, albumiij, globulin, proteose-peptone, and non-protein nitrogen of milk. The method is accurate, rapid, and particularly suitable for the determination of the smaller nitrogen fractions.

The various nitrogen fractions are separated by the improved procedures described in the preceding paper.

The aim of this study was to identify whey-derived peptides with angiotensin I-converting enzyme (ACE) inhibitory activity. The bovine whey proteins α-lactalbumin and β-lactoglobulin were hydrolysed with pepsin, trypsin, chymotrypsin, pancreatin, elastase or carboxypeptidase alone and in combination. The total hydrolysates were fractionated in a two step ultrafiltration process, first with a 30 kDa membrane and then with a 1 kDa membrane. Inhibition of ACE was analysed spectrophotometrically. The peptides were isolated by chromatography and identified by mass and sequencing analysis. The most potent inhibitory peptides were synthesized by the 9-fluorenylmethoxycarbonyl solid phase method. Inhibition of ACE was observed after hydrolysis with trypsin alone, and with an enzyme combination containing pepsin, trypsin and chymotrypsin. Whey protein digests gave a 50 % inhibition (IC50) of ACE activity at concentration ranges within 345–1733 μg/ml. The IC50 values for the 1–30 kDa fractions ranged from 485 to 1134 μg/ml and for the <1 kDa fraction from 109 to 837 mg/ml. Several ACE-inhibitory peptides were isolated from the hydrolysates by reversed-phase chromatography, and the potencies of the purified peptide fractions had IC50 values of 77–1062 μM. The ACE-inhibitory peptides identified were α-lactalbumin fractions (50–52), (99–108) and (104–108) and β-lactoglobulin fractions (22–25), (32–40), (81–83), (94–100), (106–111) and (142–146).

When skim milk at pH 6·55 was heated (75 to 100 °C for up to 60 min), the casein micelle size, as monitored by photon correlation spectroscopy, was found to increase during the initial stages of heating and tended to plateau on prolonged heating. At any particular temperature, the casein micelle size increased with longer holding times, and, at any particular holding time, the casein micelle size increased with increasing temperature. The maximum increase in casein micelle size was about 30–35 nm. The changes in casein micelle size were poorly correlated with the level of whey protein denaturation. However, the changes in casein micelle size were highly correlated with the levels of denatured whey proteins that were associated with the casein micelles. The rate of association of the denatured whey proteins with the casein micelles was considerably slower than the rate of denaturation of the whey proteins. Removal of the whey proteins from the skim milk resulted in only small changes in casein micelle size during heating. Re-addition of β-lactoglobulin to the whey-protein-depleted milk caused the casein micelle size to increase markedly on heat treatment. The changes in casein micelle size induced by the heat treatment of skim milk may be a consequence of the whey proteins associating with the casein micelles. However, these associated whey proteins would need to occlude a large amount of serum to account for the particle size changes. Separate experiments showed that the viscosity changes of heated milk and the estimated volume fraction changes were consistent with the particle size changes observed. Further studies are needed to determine whether the changes in size are due to the specific association of whey proteins with the micelles or whether a low level of aggregation of the casein micelles accompanies this association behaviour. Preliminary studies indicated lower levels of denatured whey proteins associated with the casein micelles and smaller changes in casein micelle size occurred as the pH of the milk was increased from pH 6·5 to pH 6·7.

The dissociation of caseins of different types from casein micelles in milk, acidified to different pH values in the range 4·9–6·7, and at temperatures of 4, 20 and 30 °C, has been studied. In contrast to a number of previous findings, it was shown that caseins of all types were dissociated from the micelles, although in all cases β-casein was in highest concentration. The amounts and proportions of all of the caseins were found to be pH- and temperature-dependent, especially the former. Studies of the proportions of the different caseins liberated suggested that, at a defined temperature, the proportions of κ;- and αs2-caseins were independent of pH, while the proportions of β- and αsl-caseins were variable, changes in one being compensated by changes in the other. The manner in which the proportions of the αsl-casein and β-caseins changes with pH was found to be temperature-dependent.

The effect of a range of milk heat treatments on the rheological properties, at small and large deformations, of acid skim milk gels was investigated. Gels were made from reconstituted skim milk heated at 75, 80, 85 and 90°C for 15 or 30 min by acidification with glucono-δ-lactone at 30°C. Gels were also made from skim milk powder (SMP) samples that had been given a range of preheat treatments during powder manufacture. Heating milks at temperatures [ges ]80°C for 15 min increased the storage moduli (G′) compared with unheated milk and produced gels with G′ in the range 300–450 Pa. Acid gels made from high-heat or medium-heat SMP had higher G′ than gels made from low-heat or ultra-low-heat SMP. Cooling gels to low temperatures resulted in an increase in G′. The yield stress of gels slightly decreased with mild heat treatments of milk, and then increased again to a maximum, finally decreasing slightly with very high heat treatments of milk. The strain at yielding decreased markedly with increasing heat treatment of milk, making these gels brittle and easier to fracture. We propose that denatured whey proteins aggregated with casein particles during the acidification of heated milk and were responsible for most of the effects observed in this study.

Measurements of the release of Ca, Mg and inorganic phosphate(Pi) from the casein micelles of bovine milk have been made, as functions of the pH, in the range 4·9–6·7, and at temperatures of 4, 20 and 30 °C. The results are in general agreement with earlier published studies in giving a value of 1·75–1·84 for the micellar Ca:Pi ratio. Mg appeared to behave similarly to Ca, although the amounts of micellar material were much smaller. The results on the acid-solvation of calcium phosphate are considered in relation to published quantitative studies of the pH-induced dissociation of the different types of caseins from the micelle, and of the micellar dissociation caused when micellar calcium phosphate is dissolved at neutral pH. It is evident from this that at present it is not possible to derive a universal relation between the dissociation of minerals and of caseins from the micelles at different temperatures and under different conditions.

Chemical and microbiological composition of four Argentinean kefir grains from different sources as well as characteristics of the corresponding fermented milk were studied. Kefir grains CIDCA AGK1, AGK2 and AGK4 did not show significant differences in their chemical and microbiological composition. In contrast, protein and yeast content of AGK3 was higher than in the other grains. Although grain microflora comprised lactobacilli, lactococcus, acetic acid bacteria and yeast, we found an important difference regarding species. Lactococcus lactis subsp. lactis, Lactobacillus kefir, Lactobacillus plantarum, Acetobacter and Saccharomyces were present in all types of kefir grain. While Leuconostoc mesenteroides was only isolated from grains CIDCA AGK1 and Lactococcus lactis subsp. lactis biovar diacetylactis, Lactobacillus parakefir and Kluyveromyces marxianus were only isolated from CIDCA AGK2 grains. All grains produced acid products with pH between 3·5 and 4·0. The apparent viscosity of AGK1 fermented milk was greater than the product obtained with AGK4. All fermented milks had inhibitory power towards Escherichia coli but AGK1 and AGK2 supernatants were able to halt the bacterial growth for at least 25 h. Grain weight increment in AGK1, AGK2 and AGK3 during growth in milk did not show significant differences. Despite their fermenting activity, AGK4 grains did not increase their weight.

In all, 4379 isolates from 35 products, including 24 artisanal cheeses, were surveyed with a view to identifying strains that could be used as starters in commercial dairy fermentations. Of the isolates, 38% were classified as Lactococcus, 17% as Enterococcus, 14% as Streptococcus thermophilus, 12% as mesophilic Lactobacillus, 10% as Leuconostoc and 9% as thermophilic Lactobacillus. Acid production by the isolates varied considerably. Of the 1582 isolates of Lactococcus and 482 isolates of mesophilic Lactobacillus tested, only 8 and 2% respectively produced sufficient acid to lower the pH of milk to <5·3 in 6 h at 30°C. In contrast, 53, 32 and 13% of Str. thermophilus, thermophilic Lactobacillus and Enterococcus isolates respectively reduced the pH to 5·3. These isolates were found only in some French, Italian and Greek cheeses. Bacteriocins were produced by 11% of the 2257 isolates tested and 26 of them produced broad-spectrum bacteriocins which inhibited at least eight of the ten target strains used, which included lactic acid bacteria, clostridia and Listeria innocua. The most proteolytic of the 2469 isolates tested were Str. thermophilus from Fontina cheese followed by Enterococcus from Fiore Sardo and Toma cheese and thermophilic Lactobacillus from all sources. Exopolysaccharides were produced by 5·3% of the 2224 isolates tested.

Differential scanning calorimetry (DSC) was used to study thermal transitions of the following whey proteins and enzymes in milk ultrafiltrate solution: β-lactoglobulin, α-lactalbumin, serum albumin, γ-globulin, apo- and Fe-lactoferrin, lysozyme, ribonuclease, α-chymotrypsin and xanthine oxidase. Denaturation enthalpies (ΔHD), denaturation temperatures (TD) and the half width of the denaturation peaks in DSC thermograms (ΔT½D) were determined and the degree of renaturation was estimated by rescanning previously denatured samples. A fair correlation between the results obtained by DSC and other more classical methods was found in general. However, for some proteins (α-lactalbumin, lysozyme, ribonuclease and xanthine oxidase), which have so far been considered relatively thermostable, calorimetry reveals conformational changes starting at temperatures as low as about 45 °C. In these cases thermostability observed after heat treatment of milk should be interpreted in terms of renaturation and not of high temperatures of denaturation.

Milk fat globule membranes (MFGM) were isolated from the milk of mid-lactation Holstein cows. The purified MFGM were fractionated using 1-dimensional SDS gels. Tryptic peptides from gel slices were further fractionated on a micro-capillary high performance liquid chromatograph connected to a nanospray-tandem mass spectrometer. Analysis of the data resulted in 120 proteins being identified by two or more unique peptide sequences. Of these 120 proteins, 71% are membrane associated proteins with the remainder being cytoplasmic or secreted proteins. Only 15 of the proteins identified in the cow MFGM were the same as proteins identified in previous mouse or human MFGM proteomic studies. Thus, the bulk of the proteins identified are new for bovine MFGM proteomics. The proteins identified were associated with membrane/protein trafficking (23%), cell signalling (23%), unknown functions (21%), fat transport/metabolism (11%), transport (9%), protein synthesis/folding (7%), immune proteins (4%) and milk proteins (2%). The proteins associated with cell signalling or membrane/protein trafficking may provide insights into MFGM secretion mechanisms. The finding of CD14, toll like receptor (TLR2), and TLR4 on MFGM suggests a direct role for the mammary gland in detecting an infection.

A new method for monitoring the terminal stages of proteolysis in cheese, i.e. the formation of free amino acids, using the Cd-ninhydrin reagent is reported. The assay was very specific for free amino acids and may be performed on citrate-soluble, water-soluble or phosphotungstic acid-soluble fractions of cheese, but not on trichloroacetic acid-soluble extracts; water-soluble extracts were chosen for routine analysis. Application of the assay to several experimental cheeses showed almost linear increases in free amino acids during ripening for up to 12 months with a slightly faster rate of formation during the later stages of ripening.

The effect of interactions of denatured whey proteins with casein micelles on the rheological properties of acid milk gels was investigated. Gels were made by acidification of skim milk with glucono-δ-lactone at 30°C using reconstituted skim milk powders (SMP; both low- and ultra-low-heat) and fresh skim milk (FSM). The final pH of the gels was ∼4·6. Milks containing associated or ‘bound’ denatured whey proteins (BDWP) with casein micelles were made by resuspending the ultracentrifugal pellet of heated milk in ultrafiltration permeate. Milks containing ‘soluble’ denatured whey protein (SDWP) aggregates were formed by heat treatment of an ultracentrifugal supernatant which was then resuspended with the pellet. Acid gels made from unheated milks had low storage moduli, G′, of <20 Pa. Heating milks at 80°C for 30 min resulted in acid gels with G′ in the range 390–430 Pa. The loss tangent (tan δ) of gels made from heated milk increased after gelation to attain a maximum at pH ∼5·1, but no maximum was observed in gels made from unheated milk. Acid gels made from milks containing BDWP that were made from low-heat SMP, ultra-low-heat SMP and FSM had G′ of about 250, 270 and 310 Pa respectively. Acid gels made from milks containing SDWP that were made from ultra-low-heat SMP or FSM had G′ values in the range 17–30 Pa, but gels made from low-heat SMP had G′ of ∼140 Pa. It was concluded that BDWP were important for the increased G′ of acid gels made from heated milk. Addition of N-ethylmaleimide (NEM) to low-heat reconstituted milk, to block the —SH groups, resulted in a reduction of the G′ of gels formed from heated milk but did not reduce G′ to the value of unheated milk. Addition of 20 mm-NEM to FSM, prior to heat treatment, resulted in gels with a lower G′ value than gels made from reconstituted low-heat SMP. It was suggested that small amounts of denatured whey proteins associated with casein micelles during low-heat SMP manufacture were probably responsible for the higher G′ of gels made from milk containing SDWP and from milk heated in the presence of 20 mm-NEM, compared with gels made from FSM.

A model to calculate the economic losses of mastitis on an average Dutch dairy farm was developed and used as base for a tool for farmers and advisors to calculate farm-specific economic losses of mastitis. The economic losses of a clinical case in a default situation were calculated as €210, varying from €164 to €235 depending on the month of lactation. The total economic losses of mastitis (subclinical and clinical) per cow present in a default situation varied between €65 and €182/cow per year depending on the bulk tank somatic cell count. The tool was used to measure perception of the total economic losses of mastitis on the farm and the farmers' assessment of the cost factors of mastitis on 78 dairy farms, of which 64 were used for further analyses. Most farmers (72%) expected their economic losses to be lower than those revealed by our calculation made with their farm information. Underestimating the economic losses of mastitis can be regarded as a general problem in the dairy sector. The average economic losses assessed by the farmers were €78/cow per year, but a large variation was given, €17–198/cow per year. Although the average assessment of the farmers of the different cost factors is close to the default value, there is much variation. To improve the adoption rate of advice and lower the incidence of mastitis, it is important to show the farmers the economic losses of mastitis on their farm. The tool described in this paper can play a role in that process.

Effects of high pressure (HP) on average casein micelle size and denaturation of α-lactalbumin (α-la) and β-lactoglobulin (β-lg) in raw skim bovine milk were studied over a range of conditions. Micelle size was not influenced by treatment at pressures <200 MPa, but treatment at 250 MPa increased micelle size by ∼25%, while treatment at [ges ]300 MPa irreversibly reduced it to ∼50% of that in untreated milk. The increase in micelle size after treatment at 250 MPa was greater with increasing treatment time and temperature and milk pH. Treatment times [ges ]2 min at 400 MPa resulted in similar levels of micelle disruption, but increasing milk pH to 7·0 partially stabilised micelles against HP-induced disruption. Denaturation of α-la did not occur [les ]400 MPa, whereas β-lg was denatured at pressures >100 MPa. Denaturation of α-la and β-lg increased with increasing pressure, treatment time and temperature and milk pH. The majority of denatured β-lg was apparently associated with casein micelles. These effects of HP on casein micelles and whey proteins in milk may have significant implications for properties of products made from HP-treated milk.

This study was designed to evaluate the respective influences of stage of lactation (SOL) and time of year on the seasonal variation in milk composition for pasture-fed dairy cows in New Zealand. Four herds of ∼20 Friesian cows were used, one herd calving in a 6 week period beginning in each of January, April, July and October. Cows grazed rye-grass–white clover pasture only, except during June when all cows received supplementary pasture silage. Milk samples were collected from each cow in milk on four occasions during the year (September, December, March and June), to give a total of three samples per cow (early, mid and late lactation; about 30, 120 and 210 d respectively after calving). Samples were analysed for a detailed range of components. Concentrations of many milk components (e.g. total protein, fat, casein and whey protein) increased as lactation progressed; the extent of these increases depended on the time of year. These results indicated that spreading calving throughout the year would lessen seasonal variations in the gross composition of milk supplied to factories, leading to a more even distribution of product yield across the year. Despite this, variations in some important manufacturing properties were affected by time of year but not by SOL. Ratios of protein[ratio ]fat and casein: whey protein were not significantly affected by SOL, but were affected by time of year. The solid fat content of milk was also affected by time of year. Seasonal variations in the manufacturing properties of milk may be reduced but not eliminated by changing the time of calving.

Although widely adopted by the chemical and pharmaceutical industries in recent years, little published data is available regarding possible applications of high pressure homogenisation for dairy products. The objective of this work was to compare the effects of conventional (18 MPa, two-stage) and single or two-stage high pressure homogenisation (HPH) at 50–200 MPa on some properties of raw whole bovine milk (∼4% fat). Fat globule size decreased as HPH pressure increased and, under certain conditions of temperature and pressure, HPH yielded significantly smaller fat globules than conventional homogenisation. Fat globule size was also affected by milk inlet temperature. The pH of all homogenised milk samples decreased during 24 h refrigerated storage. Total bacterial counts of milk were decreased significantly (P<0·05) for milk samples HPH-treated at 150 or 200 MPa. Whiteness and rennet coagulation properties of milk were unaffected or enhanced, respectively, as homogenisation pressure was increased. Average casein micelle size decreased slightly when skim milk was homogenised at 200 MPa. Thus, HPH treatment has several, potentially significant, effects on milk properties.