Four lactating Holstein cows (average milk yield: 20±3 l/d) were used to develop and validate a method for estimating the size of udder cisterns (Sinus lactiferi) using ultrasonography. A sectorial transducer probe of 5 MHz, placed in contact with the teat in a parallel cranial position, was used to obtain vertical scans of the udder in two perpendicular planes with the teat canal axis as reference. Udder scans for each udder quarter were taken randomly at intervals of 4, 8, 12, 16, 20 and 24 h after milking. Glandular parenchyma (echogenic) and lumen of the cisterns full of milk (anechogenic) were evident in the scans, the calculated area of the anechogenic portion being defined as cistern area. Cistern areas measured in perpendicular scans were highly correlated. Immediately after each measurement, cisternal milk was removed from each quarter using a teat cannula after i.v. injection of an oxytocin-receptor blocking agent. Alveolar milk from each quarter was then obtained by machine milking after i.m. injection of oxytocin. Cistern area and cisternal milk volume increased with length of milking interval showing a curvilinear pattern with a plateau after 16 h. Correlations between cistern area and cisternal milk volume were positive and significant (P<0·001) at all intervals but showed the highest values with the smallest residual standard deviations at 8 h (r=0·88) and 12 h (r=0·84). Since 8 h has previously been identified as a suitable time at which to determine cisternal milk volume for the purposes of defining suitability for different milking strategies, we conclude that ultrasonography provides a satisfactory, non-invasive method for determination of milk storage characteristics in dairy cows.

Twenty-two Murciano-Granadina dairy goats were used to investigate the effects of organic Zn supplementation of a diet containing a high level of inorganic Zn. Goats were kept in pens, machine milked once a day throughout lactation and fed a diet based on a dehydrated mixture of whole-plant maize and alfalfa ad libitum, alfalfa pellets, barley grain and a concentrate mixture. Treatments were: (1) control, and (2) supplemented with 1 g/d Zn-Methionine (Zn-Met) included in the concentrate mixture. After parturition, goats were blocked in week 3 and dietary treatments were applied until week 23. From weeks 3–20, feed intake, milk yield, milk composition, milk somatic cell count (SCC), and udder health were measured. In week 21, all goats were injected intraperitoneally with 1 g/d DL-methionine for 5 d to establish the effects of methionine under the conditions of udder stress induced by hand milking on the second day. During weeks 22 and 23, diet digestibility, and N and Zn balance were determined. Dry matter intake, milk yield, and milk contents of total solids, fat, total and true protein, and casein did not differ between treatments, but whey protein and non-protein nitrogen contents were significantly lower for the Zn-Met group. Milk SCC tended to decrease as a result of Zn-Met supplementation but differences between treatments were not significant when halves with persistent infection were excluded. Hand milking increased SCC in both groups, but udders of supplemented goats showed a lower reaction. Apparent absorption of N significantly increased and Zn retention tended to increase in Zn-Met supplemented goats. We conclude that Zn-Met supplementation can enhance resistance to udder stress in dairy goats. Effects were attributed to the organic Zn and not to the methionine component. Zn retention and protein utilization were also improved by the Zn-Met supplement.

Damage to, or deterioration of, the keratinized horn tissue of the bovine hoof claw culminates ultimately in the development of solear ulceration. We have observed abnormal keratin distribution at the site of solear ulceration in the bovine claw that may be due to alteration of the positional cues of the keratinocytes. In this study we have characterized key cell biological changes associated with ulceration in the claw that may precipitate abnormal keratinization. Loss of basement membrane at sites of ulceration was found by immunofluorescent detection of laminin and integrins. In other tissues, basement membrane breakdown results from degradation by matrix metalloproteinases (MMPs). Similarly, elevated levels of MMPs 2 and 9 were observed in ulcerated bovine claw tissue both by zymography and, quantitatively, by assay of enzyme activity. In the sole of claws that contained an ulcer, tissue distal to the ulcer site also had elevated MMP 2 when compared with healthy sole tissue from the same animals, as did sole tissue of claws recovering from ulceration. Tissue inhibitor of metalloproteinase 2 (TIMP 2) was detected by ELISA in healthy tissue. TIMP 2 tended to be lower in diseased tissue distal to ulcer sites, and was significantly lower in ulcerated tissue. MMP 2 was located by immunofluorescence in the dermal and basal epidermal region of sole tissue, in the region of the basement membrane. Increased punctate staining of material in the dermis was associated with ulcerated material. ELISA of TIMP 2 in tissue extracts enriched for dermis or epidermis confirmed that the inhibitor was located predominantly in the dermis. To investigate a possible causal relationship between basement membrane anchorage and epidermal keratinization, the effect of function-blocking antibodies to laminins and integrins was tested in tissue explant cultures prepared from healthy sole tissue. Anti-integrin antibody treatment had no effect on either protein or DNA synthesis. In contrast, in the presence of anti-laminin antibody, protein synthesis was decreased in a concentration-dependent manner, a significant effect being observed at the highest concentration after treatment for 24 h. At this concentration, DNA synthesis was also decreased after 48 h of culture, an effect that may be relevant to a hibernal reduction in claw cell turnover, and the associated seasonal vulnerability of cows to claw damage. The results provide evidence for basement membrane disruption at ulcer sites, and an increased potential for disruption in the diseased claw, and a causal link between this and abnormal epidermal keratinization. Basement membrane disruption is in turn associated with reciprocal changes in MMPs and their inhibitors, favouring extracellular proteolysis. Whether MMP activation is the primary cause of dermal–epidermal deterioration and, if so, how MMP activation is triggered, remains to be determined.

Here we report the entire cDNA sequences for equine αS1-, β- and κ-casein. Based on interspecies comparison, nine exons were found in equine β-casein and five in κ-casein. In equine αS1-casein cDNA the exon 5 was missing, which resulted in the total of 18 exons instead of 19 theoretically possible exons in αS1-casein cDNA. Comparison of DNA sequences representing exon 5 in other species with corresponding equine genomic region confirmed the presence of cryptic exon in horse genomic DNA. Equine αS1-casein mRNA was present in three forms in the lactating mammary gland and we showed that the two shorter forms were produced by skipping either the exon 8 or exon 15. In horse, as in some other mammals, β- and κ-casein are considerably more conserved (sequence identity 53% to 59% and 57% to 67%, respectively) than αS1-casein which appears as the most variable casein among species (sequence identity 40% to 54%). Interestingly, horse caseins resemble human much more than bovine caseins which may also explain the high dietetic value of mares' milk.

Chymosin, an aspartyl proteinase, is used for curdling of milk and manufacture of cheese. We report the purification and the physicochemical properties of chymosin isolated from the abomasal tissue of buffalo calves. The enzyme preparation extracted from buffalo abomasal tissues could be purified 29–fold using anion exchange and gel filtration chromatography. The molecular weight of the purified enzyme was 35·6 kDa on SDS-PAGE. Partial N-terminal amino acid sequence of the first eight amino acid sequences of buffalo chymosin was identical to the first eight amino acid sequences of cattle chymosin. Buffalo chymosin exhibited a skewed bell-shaped stability profile as a function of temperature with maximum activity near 55 °C. Milk clotting activity decreased gradually as pH increased. The enzyme became completely inactive, however, above pH 7·0. The ratio of milk clotting to proteolytic activity was 3·03. When compared with cattle chymosin, there were subtle differences in the stability and relative proteolytic activity of buffalo chymosin.

Milk contains the alkaline proteinase plasmin and lysosomal proteinases; the significance of the latter is ill-defined. The objective of this study was to investigate composition and activities of several different proteolytic enzymes in milk samples of varying somatic cell count (SCC). Increasing milk SCC was correlated with increased plasmin, cathepsin D and cysteine protease activities, with concomitant increases in proteolysis in milk. Addition of plasmin inhibitors confirmed the heterogeneity of proteinase activities in milk, as urea-PAGE analysis of milk samples showed casein hydrolysis in milk after 7 d storage even in samples with inhibitors added; extent and heterogeneity of proteolysis was correlated with milk SCC. Rennet coagulation properties were not significantly correlated with SCC, or activities of measured enzymes. Milk of increasing SCC also exhibited decreased physical stability during incubation of milk at 37 °C. Pasteurized milk was more stable than raw milk, suggesting that the enzyme(s) or mechanisms leading to such instability are impaired by pasteurization. Overall, milk has a very heterogeneous proteolytic enzyme population, with a higher significance of non-plasmin enzymes, such as cathepsin D and cysteine proteinases, than perhaps previously recognised.

Bovine β-lactoglobulin was hydrolyzed with trypsin or chymotrypsin before, during and after treatment at 600 MPa and pH 6·8 for 10 min at 30, 37 and 44 °C. The extent of β-lactoglobulin hydrolysis under pressure was noticeably higher than at atmospheric pressure, particularly when chymotrypsin was used. Addition of proteases at ambient pressure to previously pressure-treated β-lactoglobulin gave only a modest increase in proteolysis with respect to the untreated protein. Products of enzyme hydrolysis under pressure were separated by reverse-phase HPLC, and were found to be different from those obtained at atmospheric pressure when chymotrypsin was used. The residual immunochemical reactivity of the products of combined pressure-enzyme treatment was assessed on the unresolved hydrolysates by ELISA tests using polyclonal and monoclonal antibodies, and on individual hydrolytic fractions by Western Blotting using sera of paediatric patients allergic to whey proteins in cow milk. The immunoreactivity of the whole hydrolysates was related to their content of residual intact β-lactoglobulin, and no immunochemical reactivity was found for all the products of chymotrypsin hydrolysis under pressure. The results indicate that chymotrypsin effectively hydrolysed hydrophobic regions of β-lactoglobulin that were transiently exposed during the pressure treatments and that were not accessible in the native protein or in the protein that had been previously pressure treated.

The interaction of κ-casein and β-lactoglobulin is fundamental to all heat-induced modifications of milk product functionality, such as the heat stability of concentrated milks. Purified native κ-casein B and β-lg A solutions were heated at 80 °C at pH 6·7 separately and in a mixture. The circular dichroism spectra in the near UV indicated irreversible changes in the disulphide bonding patterns involving both proteins. Alkaline- and SDS-PAGE of heated samples showed that, in the presence of κ-casein, less β-lg was converted into β-lg polymers and the rate of loss of native β-lg was greater. When κ-casein was added to previously heated β-lg and the mixture was heated, the κ-casein reacted with the heat-induced β-lg polymers more readily than with the β-lg native monomers. The formation of β-lg dimers, trimers etc. was diminished. It was concluded that, when β-lg and κ-casein were heated together, β-lg formed thiol-exposed monomers, which reacted with each other or with the native κ-casein depending on the relative concentrations of β-lg and κ-casein. The products of these reactions included some disulphide-bonded 1[ratio ]1 β-lg[ratio ]κ-casein complexes, some monomer κ-casein and a range of large aggregates held together by either or both disulphide bonds and hydrophobic association.

When skim milk at pH 6·55 was heated (75 to 100 °C for up to 60 min), the casein micelle size, as monitored by photon correlation spectroscopy, was found to increase during the initial stages of heating and tended to plateau on prolonged heating. At any particular temperature, the casein micelle size increased with longer holding times, and, at any particular holding time, the casein micelle size increased with increasing temperature. The maximum increase in casein micelle size was about 30–35 nm. The changes in casein micelle size were poorly correlated with the level of whey protein denaturation. However, the changes in casein micelle size were highly correlated with the levels of denatured whey proteins that were associated with the casein micelles. The rate of association of the denatured whey proteins with the casein micelles was considerably slower than the rate of denaturation of the whey proteins. Removal of the whey proteins from the skim milk resulted in only small changes in casein micelle size during heating. Re-addition of β-lactoglobulin to the whey-protein-depleted milk caused the casein micelle size to increase markedly on heat treatment. The changes in casein micelle size induced by the heat treatment of skim milk may be a consequence of the whey proteins associating with the casein micelles. However, these associated whey proteins would need to occlude a large amount of serum to account for the particle size changes. Separate experiments showed that the viscosity changes of heated milk and the estimated volume fraction changes were consistent with the particle size changes observed. Further studies are needed to determine whether the changes in size are due to the specific association of whey proteins with the micelles or whether a low level of aggregation of the casein micelles accompanies this association behaviour. Preliminary studies indicated lower levels of denatured whey proteins associated with the casein micelles and smaller changes in casein micelle size occurred as the pH of the milk was increased from pH 6·5 to pH 6·7.

In the context of the general applicability of hydroxymethylfurfural (HMF), lactulose and furosine as time-temperature integrators (TTIs) for thermal processing of milk, the influence of milk fat content was studied. Formation kinetics were analysed for milk with fat content of 4·0±<0·1%. In previous experiments, it was observed that, under isothermal and non-isothermal heating conditions, formation of the three chemical compounds could be described by pseudo-zero order kinetics. Since the kinetic model was known, the experimental design could be simplified. Data were analysed by a non-linear regression procedure and results were evaluated by construction of joint confidence regions and temperature time tolerance (TTT-) diagrams. Formation kinetics of HMF and lactulose was not affected by milk fat content. Regarding furosine, significant differences were observed between kinetic parameters in whole, semi-skimmed and skimmed milk. The observed differences however were negligible in the context of process impact evaluation.

Effects of systematic environmental factors and milk production and quality traits on milk coagulation properties (MCP), and on repeatability of those traits were estimated from 979 milk samples collected once a month over a period of 2 years from 83 Finnish Ayrshire cows. Estimation was based on a multitrait animal model and REML methodology. In addition, persistence of non-coagulation of milk in individual cows, and factors associated with it were established from a sub sample of 24 cows producing non-coagulating (NC) milk at least once. MCP were at their best during the first lactation, at the beginning and at the end of lactation, and during grazing seasons. Variation in MCP with systematic environmental factors was partly due to variation in composition and quality of milk, especially in pH and ln (somatic cell count, SCC). Coefficients of repeatability for milk coagulation time and curd firmness were 0·65 and 0·68. These estimates were of the same magnitude as those for protein content, but were higher than those for daily milk yield, fat content, pH, and SCC. Based on the repeatability estimates for the milk coagulation traits and effects of the environmental factors, cows should be sampled at least three times during a lactation to estimate reliably breeding values for the milk coagulation traits. A total of 10% of the milk samples did not coagulate in 30 min after addition of rennet. Cows that produced NC milk at least once (30% of the cows) could be classified into those that produced NC milk only a few times during a lactation and those that produced NC milk at almost every sampling. Based on logistic regression analyses, peak and mid-lactation, high milk yield, low protein and fat content and high pH increased the risk of non-coagulation of milk.

Yeast extract was used as a nutrient for growing lactobacilli in reduced-fat Cheddar cheese as early growth of non-starter lactic acid bacteria (NSLAB) in Cheddar cheese is suppressed by pasteurization of milk and the hostile environment of the cheese. Reduced-fat Cheddar cheese was manufactured from 100 kg standardized milk on two occasions. After milling, the curd was divided into two portions, C and E. To control portion, C, salt was added at normal levels. A mixture of salt and yeast extract was added to the experimental, E. The cheeses were ripened for 7 months at 8 °C and assessed for proteolysis and NSLAB growth during ripening. Mean % moisture, fat, protein, salt and pH were 40·6, 20·5, 31·1, 1·72 and 5·22 respectively, in E cheeses, and 39·5, 20·5, 30·9, 1·68 and 5·22, respectively, in C cheese. NSLAB counts in E cheeses were 101, 103, 105 cfu/g compared with 0, 101, 104 cfu/g in C respectively, after 1, 7 and 30 d of ripening. After 60 d, cell densities of NSLAB were similar (∼106 cfu/g) in C and E cheese. Addition of yeast extract to curd affected neither the electrophoretic patterns of cheese nor its water-soluble N content during ripening. However, the total free amino acids were significantly higher in E cheese than C cheese throughout ripening, suggesting faster secondary proteolysis in the former cheeses. A 6-member trained descriptive panel evaluated the cheese at 7 months and found that the E cheeses had higher intensities of whey, fruity, sulphur, nutty, sweet and sour flavours, but had lower intensities of brothy flavours as compared to C cheeses. Also, the E cheeses were perceived to be more mature than corresponding C cheese. Results show that addition of yeast extract to cheese curd is a promising method of enhancing flavour development in ripened cheeses.

Cell viability, autolysis and lipolysis were studied in Cheddar cheese made using Lactococcus lactis subsp. cremoris AM2 or Lactococcus lactis subsp. cremoris HP. Cheddar cheese was made in triplicate over a 3 month period and ripened for 238 days at 8 °C. Cell viability in cheese was lower for AM2 (a non-bitter strain) than for strain HP (a bitter strain). Autolysis, monitored by the level of the intracellular marker enzyme, lactate dehydrogenase (EC 1.1.1.27) in cheese ‘juice’ extracted by hydraulic pressure, was much greater in the cheese made using AM2 than that made with HP. Lipolysis was determined by the increase during ripening of individual free fatty acids (FFA) from butyric (C4[ratio ]0) to linolenic acid (C18[ratio ]3) measured using a high performance liquid chromatographic technique. Levels of individual FFA from butyric (C4[ratio ]0) to linolenic (C18[ratio ]3) acids increased significantly (P<0·05) during ripening in cheeses made with either starter culture. Palmitic (C16[ratio ]0) and oleic (C18[ratio ]1) acids were the most abundant FFA throughout ripening in all cheeses. Levels of caprylic (C8[ratio ]0), myristic (C14[ratio ]0), palmitic (C16[ratio ]0) and stearic (C18[ratio ]0) acids were significantly higher (P<0·05) in cheeses manufactured with Lc. lactis subsp. cremoris AM2 than in cheeses manufactured with Lc. lactis subsp. cremoris HP. Differences in levels of lipolysis between strains was not due to differences in the specific lipolytic or esterolytic activities in cell free extracts of the strains as measured by activity on triolein (lipase) and p-nitrophenylbutyrate (esterase) substrates. Therefore, evidence is provided for a relationship between the extent of starter cell autolysis and the level of lipolysis during Cheddar cheese ripening.

On-farm refrigeration of milk reduces the growth rate of mesophilic bacteria so allowing longer storage time of raw milk before processing. However, refrigeration creates a selective pressure favouring the multiplication of psychrotrophic bacteria present as normal contaminants in raw milk. Psychrotrophs are killed by most of the currently employed pasteurization and sterilization treatments of milk but they can produce extracellular heat-stable proteinases and lipases, which are capable of degrading various milk components, affecting the storage-life of heat-processed milk and the quality of dairy products (Champagne et al. 1994; Shah, 1994).

The major milk fraction stored in the bovine udder, the alveolar milk, is not available for milk removal before being actively shifted to the cisternal cavities by the milk ejection reflex (Knight et al. 1994; Pfeilsticker et al. 1996). Tactile teat stimulation, provided by the liner throughout milking, causes continuous release of oxytocin from the neuro-pituitary into the blood circulation, which induces myoepithelial contraction and shifting of alveolar milk into the cistern until the end of milking (Bruckmaier et al. 1994; Crowley & Armstrong, 1992; Gorewit et al. 1983; Lefcourt & Akers, 1983). However, milk ejection during machine milking is not complete. A residual milk fraction of 10–30% remains in the udder and is only removed after administration of supraphysiological amounts of oxytocin, usually at least 10 i.u. of oxytocin injected i.v. (Bruckmaier & Blum, 1998). In dairy practice, exogenous oxytocin is often used at high dosages to treat disturbed or incomplete milk ejection. It is reported by farmers and veterinarians that after long-term use of exogenous oxytocin animals become addicted to the treatment and withdrawal of oxytocin causes reduced milk ejection.

Inbreeding indicates the degree of homozygosity at a locus within a population. Normally inbreeding is estimated in terms of a coefficient calculated from the pedigree of an individual. If no history is available, however, there is no way to estimate the inbreeding coefficient. Sometimes, data on individuals are missing, and that too can prevent the estimation of the inbreeding coefficient, which is essential for formulation of a breeding programme at the farm level and for breed development.