In both conventional and automatic milking systems (AMS), sensitive and reliable mastitis detection is important for profitable milk production. Mastitis detection parameters must be able to detect mastitis when the somatic cell count (SCC) is only slightly elevated. Owing to the pre-milking teat cleaning process in AMS, sampling cannot take place before the occurrence of alveolar milk ejection and importantly, this can affect the ability of parameters to detect mastitis. The aim of the present study was to examine the effect of alveolar milk ejection on l-lactate, lactate dehydrogenase (LDH), serum albumin (SA) and immunoglobulin G (IgG) compared with SCC, a commonly used indicator of mastitis. In this experiment, milk samples were collected every 20 s from one quarter during a 120-s manual teat stimulation in ten cows. Samples were analysed for SCC, l-lactate, LDH, SA and IgG. Quarters were grouped by low (<5·0 log10 cells/ml), mid (5·0–5·7 log10 cells/ml), and high (>5·7 log10 cells/ml) SCC using the sample at t=0 s. Neither l-lactate nor LDH could statistically differentiate between low and mid-SCC quarters, but there were a significant difference in levels between the high-SCC quarters and low and mid-SCC quarters. SA could not differentiate between the low and mid-SCC quarters, but the SA levels for the high SCC quarters remained statistically different compared with low and mid-SCC quarters throughout the experiment. IgG could statistically differentiate between low and mid-SCC, although the high-SCC quarters were not statistically different from the mid-SCC quarters after 60 s. In the high-SCC quarters, a decrease was shown in all parameters during milk ejection, after t=60 s. In conclusion, alveolar milk ejection reduces the effectiveness of detection parameters when compared with SCC. With the exception of IgG, the ability of other tested parameters was not satisfactory to differentiate between quarters with low to mid-SCC levels

The heat-induced changes in pH, Ca activity and viscosity after heating at 90 °C for 10 min of five modified skim milks were studied as a function of the initial pH of the milks at 25 °C. The milks had (i) different ratios of casein : whey protein (0·03, 1·74, 3·97, 5·27 and 7·25), (ii) the same total solids concentration (9% w/w) and (iii) prior to the adjustment of the pH, similar values of pH (6·67–6·74), concentration of serum calcium, and calcium activity, suggesting that the sera have similar mineral composition. The total protein concentrations of the milks differ (2·8–4·0%, w/w). The pH decrease in situ upon heating from 25–90 °C was similar for all the modified skim milks with the same starting pH, suggesting that the pH changes to milk on heating were primarily mediated by the initial mineral composition of the serum and were unaffected by the casein : whey protein ratio or the total protein content of the milk. The heat-induced changes in pH and calcium activity were largely reversible on cooling. The two milks with the lowest ratios of casein to whey protein gelled on heating to 90 °C for 10 min and cooling to 25 °C when the pH was adjusted to pH = 6·2 prior to heating. The viscosities of all other milks with casein to whey protein ratio of 3·97, 5·27 and 7·25 and/or pH ≥6·7 prior to heating did not change significantly. The effect of casein : whey protein ratio and the pH are the dominant factors in controlling the susceptibility to thickening of the milks on heating in this study.

In this work, an active coating and modified atmosphere packaging (MAP) were investigated to prolong the shelf life of Fiordilatte packaged in traditional brine. First, the screening of MAP was performed in order to select the best gas composition. Then, the combined effect of MAP and coating was investigated. Finally, the coating was loaded with potassium sorbate and its effects under MAP conditions were also assessed. Results highlighted that MAP was able to control growth of the main spoilage microbial group (Pseudomonas spp.); however, the solubilisation of carbon dioxide into the brine compromised Fiordilatte texture. Therefore, the presence of the active coating avoided the damage of gas solubilisation and promoted a shelf life prolongation by about 157%.

Relationships between fatty acids (FAs) in plant oils included in goat diets and milk fat C18 isomers were determined by Principal Factor Analysis (PFA). The three first principal factors (PF1, PF2 and PF3) accounted for 64·5% of the total variation in milk FAs contents. Fatty acids with a double bond at carbons 13, 14, 15 or 16 had high (>0·6) and positive loadings for PF1, trans-4 to trans-8 C18:1 for PF2, whereas trans-10 C18:1, trans-11 C18:1 and cis-9 trans-11 C18:2 showed high and positive loadings for PF3. Pearson's correlations supported that PF1, PF2 and PF3 were related to α-linolenic, oleic and linoleic acid intakes, respectively. Our results show that the quantitatively main FAs in plant lipids supplemented to dairy ruminants are often the main cause of the observed changes in milk C18 isomer contents. However, sometimes the observed changes are caused, or at least are influenced, by other FAs present in lower quantities in the plant lipids. Thus, using mixtures of plant oils with differently unsaturated main FAs could be a way of tailoring milk fat composition to a pre-designed pattern.

The aim of the study was to assess the effects of partial replacement of soybean meal with a protein-equivalent amount of rapeseed cake in the diet on milking parameters and fatty acid (FA) composition of milk in dairy cows. Two groups of Holstein-Friesian cows, 8 each, consisting of randomised blocks were studied: a control group (C) was given a traditional high-protein supplement (extracted soybean meal) and the experimental group (E), had part of extracted soybean meal replaced with rapeseed cake. Dry matter intake and milk yield in both groups were not affected by the diet but milk fat percentage and yield were decreased in both groups. Rapeseed cake had no effect on milk acidity or on protein (including casein) and lactose contents. A lower concentration of urea in milk in E group indicated a proper ratio of protein to energy in the fodder. Health condition of mammary gland and indicators of metabolic profile were not affected by rapeseed cake supplementation. In E group, the share of atherogenic saturated fatty acids (FA) was reduced after 11 weeks: palmitic, by 26% and myristic, by 22%; moreover, as compared with control cows, the content of monounsaturated FA in milk increased by 44% after 3 weeks and by 68% after 11 weeks, t-18:1 and c-9 t-11 isomer of CLA increased about 2·5-fold after 11 weeks. In E group, the atherogenic index (AI) was significantly (P < 0·001) lower than in C (by 54% on average) and the decrease with time was considerable (by 29%, P < 0·001). Contents of odd- and branched- chain FA in milk were not significantly affected thus reflecting proper rumen function. Partial replacement of soybean meal with rapeseed cake in the diet of cows may improve both milking indices and FA profile of milk.

Growth hormone (GH) is encoded by the GH gene, which may be single copy or duplicate in sheep. The two copies of the sheep GH gene (GH1/GH2-N and GH2-Z) were entirely sequenced in one 106 ewes of Sarda breed, in order to highlight sequence polymorphisms and investigate possible association between genetic variants and milk traits. Milk traits included milk yield, fat, protein, casein and lactose percentage. We evidenced 75 nucleotide changes. Transcription factor binding site prediction revealed two sequences potentially recognised by the pituitary-specific transcription factor POU1FI at the GH1/GH2-N gene, which were lost at the promoter of GH2-Z, which might explain the different tissues of expression of GH1/GH2-N (pituitary) and GH2-Z (placenta). Significant differences in milk traits were observed among genotypes at polymorphic loci only for the GH2-Z gene. Sheep with homozygote genotype ss748770547 CC had higher fat percentage (P < 0·01) than TT. SNP ss748770547 was part of a potential transcription factor binding site for C/EBP alpha (CCAAT/Enhancer Binding Protein), which is involved in the regulation of adipogenesis and adipoblast differentiation. SNP ss748770547, located in the GH2-Z gene 5′ flanking region, may be a causal mutation affecting milk fat content. These findings might contribute to the knowledge of the sheep GH locus and might be useful in selection processes in sheep.

Most milk-applied antioxidant assays in literature are based on the isolation and quantification of individual antioxidative compounds, whereas total antioxidant capacity (TAC) gives a more holistic picture due to cooperative action of antioxidants. Recently, the cupric reducing antioxidant capacity (CUPRAC) method has been modified to measure the antioxidant capacities of thiol-containing proteins, where the classical ammonium acetate buffer – that may otherwise precipitate proteins– was replaced with concentrated urea buffer (able to expose embedded thiol groups of proteins to oxidative attack) adjusted to pH 7.0. Thus, antioxidant capacity of milk was investigated with two competing TAC assays, namely CUPRAC and ABTS (2,2′-azinobis(3-ethylbenzothiazoline-6-sulphonic acid))/persulphate, because only these assays were capable of evaluating protein contribution to the observed TAC value. As milk fat caused turbidity, experiments were carried out with skim milk or defatted milk samples. To determine TAC, modified CUPRAC method was applied to whole milk, separated and redissolved protein fractions, and the remaining liquid phase after necessary operations. Both TAC methods were investigated for their dilution sensitivity and antioxidant power assessment of separate milk fractions such as casein and whey. Proteins like β-lactoglobulin and casein (but not simple thiols) exhibited enhanced CUPRAC reactivity with surfactant (SDS) addition. Addition of milk protein fractions to whole skim milk produced significant ‘negative-biased’ deviations (up to −26% relative standard error) from TAC absorbance additivity in the application of the ABTS method, as opposed to that of the CUPRAC method less affected by chemical deviations from Beer's law thereby producing much smaller deviations from additivity (i.e. the property of additivity is valid when the measured TAC of a mixture is equal to the sum of individual antioxidant capacities of its constituents).

Laboratory somatic cell count (LSCC) records are usually recorded monthly and provide an important information source for breeding and herd management. Daily milk viscosity detection in composite milking (expressed as drain time) with an automated on-line California Mastitis Test (CMT) could serve immediately as an early predictor of udder diseases and might be used as a selection criterion to improve udder health. The aim of the present study was to clarify the relationship between the well-established LSCS and the new trait,‘drain time’, and to estimate their correlations to important production traits. Data were recorded on the dairy research farm Karkendamm in Germany. Viscosity sensors were installed on every fourth milking stall in the rotary parlour to measure daily drain time records. Weekly LSCC and milk composition data were available. Two data sets were created containing records of 187 692 milkings from 320 cows (D1) and 25 887 drain time records from 311 cows (D2). Different fixed effect models, describing the log-transformed drain time (logDT), were fitted to achieve applicable models for further analysis. Lactation curves were modelled with standard parametric functions (Ali and Schaeffer, Legendre polynomials of second and third degree) of days in milk (DIM). Random regression models were further applied to estimate the correlations between cow effects between logDT and LSCS with further important production traits. LogDT and LSCS were strongest correlated in mid-lactation (r = 0·78). Correlations between logDT and production traits were low to medium. Highest correlations were reached in late lactation between logDT and milk yield (r = −0·31), between logDT and protein content (r = 0·30) and in early as well as in late lactation between logDT and lactose content (r = −0·28). The results of the present study show that the drain time could be used as a new trait for daily mastitis control.

The objective of the study was twofold: (i) to quantify the differences in daily milk yield (DMY) and total milk yield (TMY) between lame and non-lame dairy ewes and (ii) to determine the shape of lactation curves around the lameness incident. The overall study was a prospective study of lameness for the surveyed sheep population, with a nested study including the selection of matching controls for each lame ewe separately. Two intensively reared flocks of purebred Chios ewes and a total of 283 ewes were used. Data, including gait assessment and DMY records, were collected on a weekly basis during on-farm visits across the milking period. A general linear model was developed for the calculation of lactation curves of lame and non-lame ewes, whereas one-way ANOVA was used for the comparisons between lame ewes and their controls. Lameness incidence was 12·4 and 16·8% on Farms A and B, respectively. Average DMY in lame ewes was significantly lower (213·8 g, P < 0·001) compared with the rest of the flock, where DMY averaged 1·340 g. The highest DMY reduction in lame ewes was observed during the week 16 of the milking period (P < 0·001), whereas the reduction of DMY, for lame ewes, remained significant at P < 0·001 level from week 8 to week 28 of milking. Comparisons between lame and controls revealed that at the week of lameness diagnosis a significant DMY reduction (P ≤ 0·001) was observed in lame ewes (about 32·5%), which was maximised 1 week later (35·8%, P ≤ 0·001) and continued for several weeks after recovery, resulting in 19·3% lower TMY for lame ewes for the first 210 d of the milking period (P < 0·01). Moreover, at flock level, TMY for non-lame and lame ewes, as calculated by the general linear model, was 318·9 and 268·0 kg, respectively. The results of this study demonstrate evidence of significant financial losses in dairy sheep due to lameness which, however, need to be accurately estimated in further, more detailed, analyses.

Reliable identification of the aetiological agent is crucial in mastitis diagnostics. Real-time PCR is a fast, automated tool for detecting the most common udder pathogens directly from milk. In this study aseptically taken quarter milk samples were analysed with a real-time PCR assay (Thermo Scientific PathoProof Mastitis Complete-12 Kit, Thermo Fisher Scientific Ltd.) and by semi-quantitative, in-depth bacteriological culture (BC). The aim of the study was to evaluate the diagnostic performance of the real-time PCR assay in routine use. A total of 294 quarter milk samples from routine mastitis cases were cultured in the national reference laboratory of Finland and examined with real-time PCR. With BC, 251 out of 294 (85·7%) of the milk samples had at least one colony on the plate and 38 samples were considered contaminated. In the PCR mastitis assay, DNA of target species was amplified in 244 samples out of 294 (83·0%). The most common bacterial species detected in the samples, irrespective of the diagnostic method, was the coagulase negative staphylococci (CNS) group (later referred as Staphylococcus spp.) followed by Staphylococcus aureus. Sensitivity (Se) and specificity (Sp) for the PCR assay to provide a positive Staph. aureus result was 97·0 and 95·8% compared with BC. For Staphylococcus spp., the corresponding figures were 86·7 and 75·4%. Our results imply that PCR performed well as a diagnostic tool to detect Staph. aureus but may be too nonspecific for Staphylococcus spp. in routine use with the current cut-off Ct value (37·0). Using PCR as the only microbiological method for mastitis diagnostics, clinical relevance of the results should be carefully considered before further decisions, for instance antimicrobial treatment, especially when minor pathogens with low amount of DNA have been detected. Introducing the concept of contaminated samples should also be considered.

Propionicin PLG-1 is a bacteriocin produced by Propionibacterium thoenii P127. Such bacteriocin inhibits wide range of food-borne pathogens such as pathogenic Escherichia coli, Pseudomonas aeruginosa, Vibrio parahaemolyticus, Yersinia enterocolitica and a strain of Corynebacterium sp. In the present study, plg-1 gene expressing propionicin PLG-1 was isolated, sequenced for the first time and the resulting sequence was analysed using several web-based bioinformatics programs. The PCR product containing plg-1 gene was transferred to different lactic acid bacterial (LAB) strains using pLEB590 as a cloning vector to give the modified vector pLEBPLG-1. LAB transformants showed an antimicrobial activity against Esch. coli DH5α (most affected strain), Listeria monocytogenes 18116, and Salmonella enterica 25566 as model pathogenic strains. Such LAB transformants can be used in dairy industry to control the food-borne pathogens that are largely distributed worldwide and to feed schoolchildren in the poor countries where dangerous epidemic diseases and diarrhoea prevail.

The effect of different brining treatments on salt uptake and diffusion during the first 30 d of ripening was determined in soft ewe cheese. Additionally, salt influence on surface microorganisms and physicochemical parameters was evaluated. Cheeses were placed into different brine solutions (14, 18 and 24°Bé) at 5 and 10 °C for 1, 2 or 3 h. Samples from rind, outer core and inner core were analysed at 0, 7, 15 and 30 d. Complete salt diffusion from rind to the inner core took about 15 d. The resulting salt gradient favoured the development of a pH gradient from the surface to the inner core. Salt concentration also had a significant effect on the growth of surface microorganisms (mesophiles, pseudomonads and halotolerants). However, mould and yeasts were not affected throughout ripening by the salt levels achieved. Brine salting by immersion for 3 h at 10 °C in 24°B brine was found to be the most suitable treatment to control pseudomonads in cheese rind, as spoilage microorganism.

The aim of this study was to determine the influence of the somatic cell content (SCC) of milk on Parmigiano-Reggiano cheese yield, produced in commercial cheese factories under field conditions. The study was carried out following the production of 56 batches of Parmigiano-Reggiano in 13 commercial cheese factories by processing milk collected from Italian Friesian cattle herds. The vat-milk (V-milk) used for making each cheese batch was obtained by mixing evening milk (partially skimmed following spontaneous separation of fat overnight, natural creaming) and morning milk. The batches of cheese produced were divided into 5 classes according to the SCC value of the evening milk determined prior to natural creaming (class 1, from 0 to 200 000; 2, 201 000–300 000; 3, 301 000–400 000; 4, 401 000–500 000; 5, over 501 000 cells/ml). The cheese yield was calculated as the amount of 24-h cheese, expressed in kilograms, obtained from 100 kg of V-milk (24 h ACY). The values of fat, crude protein, true protein, casein and 24 h ACY of V-milk were negatively correlated with the somatic cell score (SCS) of the evening milk. Conversely, a positive correlation was observed between chloride and SCS. Fat, protein fractions (crude protein, casein and whey proteins), P and titratable acidity of V-milk were positively correlated with its 24 h ACY, while chloride, pH and SCS showed a negative correlation. A significant drop in 24 h ACY was observed in classes 3, 4 and 5, therefore when the SCC of the evening milk exceeded 300 000 cells/ml. Finally a lower recovery of milk fat in cheese was observed as SCC of evening milk increase.

Glucose utilisation for lactose synthesis in the mammary gland involves expression of a large number of genes whose nutritional regulation remains poorly defined. In this study, the effect of long term under- and over-feeding on the expression of genes [glucose transporter 1: GLUT1, glucose transporter 3: GLUT3, Sodium glucose contransporter 1: SGLT1, two isoforms of β- (1,4) galactosyltransferase: β- (1,4) GAT1, β- (1,4) GAT3 and α-lactalbumin: LALBA] related to glucose metabolism in sheep mammary tissue (MT) was examined. Twenty-four lactating dairy sheep were divided into three homogenous sub-groups and fed the same ration in quantities which met 70% (underfeeding), 100% (control) and 130% (overfeeding) of their energy and crude protein requirements. The results showed a significant reduction on mRNA of GLUT1 and LALBA gene in the MT of underfed sheep, compared with the respective controls and overfed and a significant reduction on mRNA level of SGLT1 and β- (1,4) GAT1 in the MT of underfed sheep, compared with the overfed ones. A significant increase in the GLUT3 mRNA accumulation in the MT of both under- and over- fed sheep was found. Additionally, a trend of reduction on β- (1,4) GAT3 mRNA level in the MT of the underfed sheep, compared with the overfed, was observed. A close positive relationship was obtained between the mRNA transcripts accumulation of GLUT1, SGLT1, β- (1,4) GAT1 and LALBA gene with the milk lactose content and milk lactose yield respectively. In conclusion, feeding level and consequently nutrient availability, may affect glucose uptake and utilisation in sheep MT by altering the GLUT1, GLUT3, SGLT1, β- (1,4) GAT1 and LALBA gene expression involved in their metabolic pathways.

Bacteriocins produced by lactic acid bacteria are of great interest to the food-processing industry as natural preservatives. This work aimed to investigate the efficacy of bacteriocin-producing Lactobacillus plantarum TF711, isolated from artisanal Tenerife cheese, in controlling Clostridium sporogenes during cheese ripening. Cheeses were made from pasteurised milk artificially contaminated with 104 spores m/l C. sporogenes. Experimental cheeses were manufactured with Lb. plantarum TF711 added at 1% as adjunct to commercial starter culture. Cheeses made under the same conditions but without Lb. plantarum TF711 served as controls. Evolution of microbiological parameters, pH and NaCl content, as well as bacteriocin production was studied throughout 45 d of ripening. Addition of Lb. plantarum TF711 did not bring about any significant change in starter culture counts, NaCl content and pH, compared with control cheese. In contrast, clostridial spore count in experimental cheeses were significantly lower than in control cheeses from 7 d onwards, reaching a maximum reduction of 2·2 log units on day 21. Inhibition of clostridia found in experimental cheeses was mainly attributed to plantaricin activity, which in fact was recovered from these cheeses.

Twenty-one Lactobacillus helveticus bacteriophages, 18 isolated from different cheese whey starters and three from CNRZ collection, were phenotypically and genetically characterised. A biodiversity between phages was evidenced both by host range and molecular (RAPD-PCR) typing. A more detailed characterisation of six phages showed similar structural protein profiles and a relevant genetic biodiversity, as shown by restriction enzyme analysis of total DNA. Latent period, burst time and burst size data evidenced that phages were active and virulent. Overall, data highlighted the biodiversity of Lb. helveticus phages isolated from cheese whey starters, which were confirmed to be one of the most common phage contamination source in dairy factories. More research is required to further unravel the ecological role of Lb. helveticus phages and to evaluate their impact on the dairy fermentation processes where whey starter cultures are used.

The tetracyclines (TCs) are widely used in the treatment of several diseases of cattle and their residues may be present in milk. To control these residues it is necessary to have available inexpensive screening methods, user-friendly and capable of analysing a high number of samples. The purpose of this study was to design a bioassay of microbiological inhibition in microtiter plates with spores of Bacillus pumilus to detect TCs at concentrations corresponding to the Maximum Residue Limits (MRLs). Several complementary experiments were performed to design the bioassay. In the first study, we determined the concentration of spores that produce a change in the bioassay's relative absorbance in a short time period. Subsequently, we assessed the concentration of chloramphenicol required to decrease the detection limit (DL) of TCs at MRLs levels. Thereafter, specificity, DL and cross-specificity of the bioassay were estimated. The most appropriate microbiological inhibition assay had a B. pumilus concentration of 1·6 × 109 spores/ml, fortified with 2500 μg chloramphenicol/l (CAP) in Mueller Hinton culture medium using brilliant black and toluidine blue as redox indicator. This bioassay detected 117 μg chlortetracycline/l, 142 μg oxytetracycline/l and 105 μg tetracycline/l by means of a change in the indicator's colour in a period of 5 h. The method showed good specificity (97·9%) which decreased slightly (93·3%) in milk samples with high somatic cell counts (>250 000 cells/ml). Furthermore, other antimicrobials studied (except neomycin) must be present in milk at high concentrations (from >5 to >100 MRLs) to produce positive results in this assay, indicating a low cross specificity.