An increase in the proportion of unsaturated fatty acids in milk is considered desirable for human health. A prerequisite for the manipulation of milk fat composition is a co-ordinated understanding of the complex interactions in its biosynthesis. It has been suggested that an increase in the expression of mammary stearoyl-CoA-desaturase (SCD) would enrich mono-unsaturated fatty acids in milk, and therefore improve its nutritional properties. To investigate the potential effects of changes in expression of mammary enzymes and substrate availability on milk fat composition, we constructed, parameterized and evaluated a mechanistic mathematical model of fatty acid biosynthesis and milk-fat triglyceride assembly. The objective was to describe changes in the amount and composition of milk fat produced by bovine mammary cells due to changes in nutrition. Using the model we found that a 50% up-regulation in SCD activity increased the molar fraction of milk triglyceride 18[ratio ]1 from 0·30 to 0·33 and 16[ratio ]1 from 0·04 to 0·06. Up-regulation of SCD therefore did not appear to be the optimal method for increasing the content of unsaturated fatty acids in milk fat. The model was also used to determine the likely rate-limiting processes for the incorporation of unsaturated fatty acids into milk fat. Halving the concentration of glycerol 3-phosphate increased the molar fraction of milk triglyceride 18[ratio ]1 from 0·30 to 0·35 and decreased the molar fraction of milk triglyceride 16[ratio ]0 from 0·30 to 0·22. This achieved the desirable outcome of producing more unsaturated low-fat milk. Our model also predicted that a K232A mutation in the bovine mammary DGAT1 gene that is linked with an increase in milk fat yield would be consistent with a 120% increase in the DGAT acylation rate and also would be associated with a decrease in milk mono-unsaturated fatty acids.

Mammary epithelial cells, which express and secrete leptin into milk, accumulate triacylglycerol (TAG). We examined effects on the accumulation of cytosolic TAG of addition of short- (acetate and butyrate) or medium- (octanoate) chain fatty acids to the medium bathing bovine mammary epithelial cells (bMEC). Octanoate stimulated the accumulation of TAG in a concentration-dependent manner from 1 to 10 mM and increased lipid droplet formation and mRNA expression of CD36 (a fatty acid translocase). Additionally, expression of a peroxisome proliferator activated receptor (PPAR) γ 2 protein that is a lipid-activated transcription factor, was increased by the addition of acetate or octanoate. However, leptin mRNA expression was significantly reduced by addition of acetate or butyrate. Both short- and medium-chain fatty acids inhibited acetyl coenzyme A carboxylase (ACC) activities, which is pivotal in lipid synthesis, but elevated expression of uncoupling protein 2 (UCP2) mRNA, which is important in energy expenditure. These results suggest that octanoate induces cytosolic TAG accumulation and the formation of lipid droplets, and that acetate and butyrate inhibit leptin expression and lipid synthesis in bMEC.

A differential allele-specific accumulation of κ-casein mRNA that is not linked to the κ-casein protein variants is described in Holstein cows. Actually, cows genotyped κ-casein AB were a mixed population. For the first group of κ-casein AB cows, allele A-specific κ-casein mRNA contents within mammary epithelial cells were lower than the allele B-specific ones (cows LH), suggesting that the allele A-specific κ-casein gene was expressed with lower efficiency in mRNA. For the other group of κ-casein AB cows, allele A- and B-specific κ-casein mRNA accumulated to a similar level within mammary epithelial cells (cows HH). The objective of this study was to determine whether the accumulation of allele-specific κ-casein mRNA remained constant throughout lactation for the two groups of cows. Quantitative RT-PCR was used to monitor Holstein cows κ-casein AB genotyped HH and LH throughout lactation for the proportion of allele B-specific mRNA accumulation relative to the total κ-casein encoded mRNA within mammary epithelial cells: RNA was extracted from milk somatic cells known to contain a small proportion of mammary epithelial cells. Mean values of allele B-specific mRNA content were 50·6±0·5 and 54·0±0·9%, for cows HH and cows LH, respectively, and did not vary during lactation (P>0·10). This suggests that the phenotypic expression of the genetic mutation that causes the differential allele-specific accumulation of κ-casein mRNA was not affected by physiological and environmental factors, which tend to vary considerably throughout lactation.

Economic decisions on animal health strategies address the cost-benefit aspect along with animal welfare and public health concerns. Decision tree analysis at an individual cow level highlighted that there is little economic difference between the use of either dry cow antibiotic or an internal teat sealant in preventing a new intramammary infection in a cow free of infection in all quarters of the mammary gland at drying off. However, a potential net loss of over £20 per cow might occur if the uninfected cow was left untreated. The only economically viable option, for a cow with one or more quarters infected at drying off, is antibiotic treatment, although a loss might still be incurred depending on the pathogen concerned and the cure rates achievable. There was a net loss for cows with quarters infected with Corynebacterium spp. at drying off, for both the teat sealant and untreated groups (£22 and £48, respectively) with only antibiotic-treated cows showing a gain.

Four milking regimes using automatic cluster removers (ACR) were tested over a 19-week period, from mid to late lactation. Each treatment group consisted of 16 slow-milking cows. The milking regimes used were: an ACR setting of 200 ml/min (Control); raised ACR setting from 200 to 500 in steps of 100 ml/min (Raised ACR); raised ACR as above in conjunction with pre-milking teat stimulation (Raised ACR+Stim); and terminating the milking when an ACR threshold of 200 ml/min was reached or when a predetermined maximum milking duration was reached (Timer). All incremental treatments were applied in blocks of 6 or 7 weeks duration. ACR thresholds were raised from 200 to 500 ml/min without observed loss of milk production when compared with controls. However, even up to an ACR setting of 500 ml/min there was little reduction in the group milking duration even when used with teat stimulation. In contrast, the Timer treatment resulted in a 34% reduction of the maximum milking duration for the group without significant loss of milk yield. For all groups, including Control, strip yield was occasionally very high and highly variable. Willingness of cows to enter the milking platform, behaviour during milking, teat condition and incidence of mastitis were similar for all treatment groups. The results indicated that simple truncation of milking at a predetermined maximum duration could be a most potent and inexpensive method of milking a herd more quickly. Such a method could be employed by using a simple timer in any dairy regardless of the level of sophistication of the milking system.

Ivermectin (IVM) and moxidectin (MXD) are broad-spectrum endectocides belonging to the avermectin/milbemycin class of antiparasitic drugs not approved for use in dairy sheep. However, these compounds are widely used extra-label to control endo- and ecto-parasites in lactating dairy sheep. Effects of the route of administration on the pattern of IVM and MXD excretion in milk were comparatively characterized in lactating dairy sheep. The relationship between the milk and plasma disposition kinetics after subcutaneous (s.c.) and oral administration at 200 μg/kg body weight was also evaluated. IVM and MXD concentration profiles were measured in milk and plasma using a specific HPLC-based methodology. IVM and MXD were extensively distributed from the bloodstream to the mammary gland and large quantities, particularly for MXD, were excreted in milk. Residual concentrations of IVM were recovered in milk up to 11 d (oral treatment) or 25 d (s.c. treatment) post treatment. However, high MXD concentrations were detected in milk between 1 h and 35 d after its oral and subcutaneous administration. MXD concentrations as high as 3·77 ng/ml (oral) and 30·3 ng/ml (s.c.) were measured in milk at day 35 post administration. A higher MXD excretion in milk, compared with that of IVM, was obtained for both administration routes. An extensive plasma to milk distribution pattern was observed, being the area under the concentration-time curve of MXD obtained in milk up to 14-fold higher than that measured in the bloodstream. The total fraction of the administered dose excreted in milk for MXD was significantly higher than that for IVM, which agrees with the well known higher MXD lipophilicity. The long persistence of milk residual concentrations of MXD and IVM in lactating dairy sheep should be seriously considered before their extra-label use is recommended.

Effects of ventilation regimen on the quality of ewes' milk and on proteolysis in Canestrato Pugliese cheese during ripening were studied. Cheeses were manufactured from the bulk milk of Comisana ewes subjected to three different ventilation regimens, which were designated low (LOV, 23 m3/h per ewe), moderate (MOV, 47 m3/h per ewe) and programmed ventilation regimen (PROV, 73 m3/h per ewe; fan set to maintain 70% relative humidity). Bulk milk was analysed for chemical and microbial composition, renneting parameters and plasmin-plasminogen activities. At 1, 15, 30 and 45 d of ripening, the cheeses were analysed for gross chemical composition, nitrogen fractions, and plasmin and plasminogen activities. The pH 4·6-insoluble nitrogen fractions were analysed by urea-PAGE. Free amino acid content was determined at the end of ripening. Lower concentrations of bulk milk somatic cell count (BMSCC) and of mesophilic bacteria were found in the MOV group than in the LOV and the PROV groups. A lower plasminogen (PG) to plasmin (PL) ratio (PG/PL) was observed in the MOV and PROV than in the LOV cheeses. Irrespective of treatment, PL activity in cheeses was higher at 15 d of ripening, while a sudden decrease of PL and PG activities was observed at 30 d, which was associated with a marked increase in non-protein nitrogen. The peptide profile characterized in the urea-PAGE showed a greater intensity of α- and β-CN hydrolysis in the MOV than in the PROV and LOV cheeses. The results provide evidence that a proper ventilation regimen is critical for optimizing the hygienic quality of milk and the proteolysis of Canestrato Pugliese cheese during ripening.

A total of 118 enterococcal strains isolated from artisanal Fiore Sardo cheese were characterized technologically and genetically. The presence of potential virulence factors was also investigated. Strains were classified as Ec. faecium (84 strains), Ec. durans (24 strains) and Ec. faecalis (10 strains). RAPD-PCR analysis with two different primers (M13 and XD9) confirmed species identification and proved useful for the detection of interstrain variations, especially among Ec. faecium isolates. Most strains could hydrolyse casein and had weak acidifying activity in milk. None of the isolates produced lipolytic reactions. Gelatinase activity was observed in two strains of Ec. faecalis and one strain of Ec. durans. β-Haemolysis on horses' blood was never detected in any of the strains, independently of species. Most strains produced tyramine from tyrosine but none decarboxylated lysine, histidine or ornithine. Overall, a wide spectrum of resistance was observed. Almost all strains were resistant to the aminoglycosides, gentamycin, kanamycin, streptomycin, neomycin, and to the semisynthetic penicillin, oxacillin, but resistance to vancomycin was not widespread among our strains: only one Ec. faecium and one Ec. durans strain were found to be vancomycin resistant. Our results show a certain diversity in technological traits of the enterococcal strains isolated from artisanal Fiore Sardo, together with a low incidence of some potentially pathogenic traits of health concern.

The aim was to select potentially probiotic lactobacilli from 88 strains isolated from unpasteurized milk and cheese products, and to incorporate these bacteria in a viable state into a soft cheese, without changing its quality. The survival of these bacteria was assessed in acidic and bile conditions, after freezing at −80 °C. Four strains from unpasteurized Camembert – two Lactobacillus plantarum strains and two Lb. paracasei/casei strains – were identified and typed by PCR and PFGE and were found to display potentially probiotic characteristics in addition to resistance to low pH and bile. These characteristics were resistance to lysozyme, adhesion to CACO-2 cells, antimicrobial effects against common foodborne pathogens (Listeria monocytogenes, Staphylococcus aureus, Salmonella spp., Escherichia coli), innocuity following the ingestion of high doses by mice and appropriate antibiotic susceptibility profiles. The potential of Lb. plantarum strain UCMA 3037 for incorporation into a soft cheese (Pont-l'Eveque registered designation of origin (RDO)) was investigated. This strain grew well and survived in sufficient numbers (more than 107 cfu/g throughout the shelf-life of the product) in the cheese. This strain did not change the quality score of the product until the best before date (75 days after manufacture). Thus, unpasteurized Camembert is a natural source of potentially probiotic lactobacilli, which could be used as an additive in the development of potentially probiotic soft cheeses. Further work is required to demonstrate the persistence and efficacy of these strains in the human host upon ingestion.

Aminotransferase (AT) activity against 18 amino acids was studied in ten strains of three species of Lactobacillus. A method for permeabilisation of cells was developed using toluene and ethanol combined with mechanical treatment. It was found that the AT activities in the washed permeabilised cells (W-PC) corresponded well to that in cell-free extracts (CFE). The AT specificity pattern was species as well as strain dependant. Strains of Lb. helveticus had high specificity for aromatic amino acids (ArAA) and lower activity against branched-chain amino acids (BcAA) and Asp, while strains of Lb. paracasei subsp. paracasei degraded BcAA and Asp, but had a lower and variable specificity against ArAA. One of the Lb. paracasei strains was characterised by having very high AT activity against all three BcAA (Ile, Leu, Val) compared with any of the other Lb. paracasei strains tested. Strains of Lb. danicus, which is a newly discovered Lactobacillus species isolated from cheese, had up to about 20 times higher AT activity against Leu than Lb. paracasei and Lb. helveticus. The permeabilised cells of Lb. danicus had also considerably higher AT activity against ArAA than Lb. paracasei and Lb. helveticus strains, and also higher AT activity against Asp. All Lactobacillus strains tested had AT activity against Met, but at a much lower rate than against other amino acids. Results of this study also demonstrated a chemical reaction between α-ketoglutaric acid and Asp that was catalysed by pyridoxal-5-phosphate without any AT present.

The changes in milk fat globules and fat globule surface proteins during concentration of whole milk using a pilot-scale multiple-effect evaporator were examined. The effects of heat treatment of milk at 95 °C for 20 s, prior to evaporation, on fat globule size and the milk fat globule membrane (MFGM) proteins were also determined. In both non-preheated and preheated whole milk, the size of milk fat globules decreased while the amount of total surface proteins at the fat globules increased as the milk passed through each effect of the evaporator. In non-preheated samples, the amount of caseins at the surface of fat globules increased markedly during evaporation with a relatively small increase in whey proteins. In preheated samples, both caseins and whey proteins were observed at the surface of fat globules and the amounts of these proteins increased during subsequent steps of evaporation. The major original MFGM proteins, xanthine oxidase, butyrophilin, PAS 6 and PAS 7, did not change during evaporation, however, PAS 6 and PAS 7 decreased during preheating. These results indicate that the proteins from the skim milk were adsorbed onto the fat globule surface when the milk fat globules were disrupted during evaporation.

Pressure processing of foodstuff has been applied to produce or modify proteinaceous gel structures. In real pressure processing the treatment is non-isothermal, due to the adiabatic nature of the process and the heat loss from the product to the vessel. In order to estimate the effect of pressurization on milk constituents pressure and temperature dependent kinetics were determined separately from each other. In a detailed kinetic study whey protein isolate was treated under isobaric (200 to 800 MPa) and isothermal conditions (−2 to 70 °C), and the resulting degree of denaturation of β-lactoglobulin A and B and α-lactalbumin was analysed. Kinetic parameters of denaturation were estimated using a one step non-linear regression method which allowed a global fit of the whole data set. The isobaric isothermal denaturation of β-lactoglobulin and α-lactalbumin was found to follow third and second order kinetics, respectively. Isothermal pressure denaturation of both β-lactoglobulin fractions do not differ significantly and were characterized by an activation volume decreasing with increasing temperature from −10 to about −30 ml mol−1, which demonstrates that the denaturation rate is accelerated with increasing temperature. The activation energy of about 70 to 100 kJ mol−1 obtained for β-lactoglobulin A and B is not dependent to a great extent on the pressure which indicates that above 200 MPa denaturation rate is limited by the aggregation rate while pressure forces unfolding of the molecule.

In this study, high pressure (HP)-induced denaturation of α-lactalbumin (α-la) and β-lactoglobulin (β-lg) in dairy systems was examined. In both milk and whey, β-lg was less baroresistant than α-la; both proteins were considerably more resistant to HP-induced denaturation in whey than in milk. HP-induced denaturation of α-la and β-lg increased with increasing proportion of milk in mixtures of milk and whey. Addition of a sulphydryl-oxidising agent, KIO3, to milk or whey increased HP-induced denaturation of β-lg, but reduced the denaturation of α-la. Denaturation of both α-la and β-lg was prevented by adding a sulphydryl-blocking agent, N-ethylmaleimide, to milk or whey prior to HP treatment, highlighting the crucial role of sulphydryl-disulphide interchange reactions in HP-induced denaturation of α-la and β-lg. Removal of colloidal calcium phosphate from milk also reduced HP-induced denaturation of α-la and β-lg significantly. The higher level of HP-induced denaturation of α-la and β-lg in milk than in whey may be the result of the abscence of the casein micelles and colloidal calcium phosphate from whey, which facilitate HP-induced denaturation of α-la and β-lg in milk.

High pressure (HP) processing has attracted considerable interest in dairy research in recent years; its effects on cheese have been reviewed by O'Reilly et al. (2001). HP treatment of cheese may influence several of its properties, e.g., for hard and semi-hard cheeses, such as Cheddar and Gouda, the most notable effects are on the texture and rate of ripening. HP treatment increased elasticity and improved organoleptic properties of Gouda cheese (Kolakowski et al. 1998). Messens et al. (2000) reported that, immediately after treatment at 400 MPa, Gouda cheese was less rigid and solid-like and more viscoelastic than untreated cheese. HP treatment also enhances the functional properties of Mozzarella cheese (Johnston & Darcy, 2000; O'Reilly et al. 2002).

Osteopontin (OPN) is an acidic phosphorylated glycoprotein found in many tissues and physiological fluids. Bovine OPN is a mature protein comprising 262 amino acids with a calculated molecular weight of 29 kDa. However, SDS-PAGE analysis reveals that the protein isolated from milk migrates to a molecular mass of 60 kDa (Sørensen & Petersen, 1993; Bayless et al. 1997). Bovine milk OPN is phosphorylated at 27 serine residues and one threonine residue (Sorensen et al. 1995); three O-glycosylated threonines were also identified, but no asparagine residues were glycosylated in spite of the presence of three putative N-glycosylation sites. In contrast, eight phosphates are recognized in bovine bone OPN (Salih et al. 1996), and 12 phosphoserines and one phosphothreonine are proposed in addition to five O-linked oligosaccharides and at most one N-linked oligosaccharide in the case of rat bone OPN (Prince et al. 1987). Thus, the possibility of tissue or species-specific differences in post-translational modification has been discussed.