Hostname: page-component-586b7cd67f-dsjbd Total loading time: 0 Render date: 2024-11-25T17:25:55.956Z Has data issue: false hasContentIssue false
  • English
  • Français

Structure and Optoelectronic Properties as a Function of Hydrogen Dilution of Micro-Crystalline Silicon Films Prepared by Hot Wire Chemical Vapor Deposition

Published online by Cambridge University Press:  15 February 2011

Guozhen Yue ,
Jing Lin ,
Qi Wang  and
Daxing Han
Guozhen Yue
Affiliation:
Department of Physics & Astronomy, University of North Carolina at Chapel Hill, Chapel Hill, NC 27599-3255, USA
Jing Lin
Affiliation:
Department of Physics & Astronomy, University of North Carolina at Chapel Hill, Chapel Hill, NC 27599-3255, USA
Qi Wang
Affiliation:
National Renewable Energy Laboratory, Golden, CO 80401, USA
Daxing Han
Affiliation:
Department of Physics & Astronomy, University of North Carolina at Chapel Hill, Chapel Hill, NC 27599-3255, USA
Get access

Abstract

Films prepared by hot wire CVD using H dilution ratio, R=H 2/SiH4, from 1 to 20 were studied by X-ray, Raman, PL, and conductivity measurements. We found that (a) when the dilution ratio reached R=3, the structure transition from amorphous to microcrystalline growth occured; meanwhile, PL spectrum showed a dual-peak at 1.3 and 1.0 eV; (b) the total intensity, band width, and peak position of the low energy PL band decreased with increasing H dilution; (c) both the Raman and PL measured from the transparent substrate side showed that initial growth tends to be amorphous and a portion of μc-Si was formed when R ≥ 5; and (d) the conductivity activation energy first decreased from 0.68 to 0.15 eV when the film transition from a- to μc-Si; then increased slightly with increasing μc-Si fraction. The results demonstrate that the variation of the H-dilution ratio has significant effects on both the film structures and the optoelectric properties.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 557: Symposium A – Amorphous and Heterogeneous Silicon Thin Films—Fundamentals to Devices—1999 , 1999 , 525
Copyright
Copyright © Materials Research Society 1999

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

1. Luysberg, M., Hapke, P., Carius, R. and Finger, F., Phil. Mag. A75, 31 (1997).Google Scholar
2. Wang, F., Wolfe, D., and Lucovsky, G. in Amorphous and Microcrystalline Silicon Technology, edited by Wagner, S., Hack, M., Schiff, E. A., Schropp, R. and Shimizu, I. (Mat. Res. Soc. Symp. Proc. 467, 1997) pp. 433–438; References therein.Google Scholar
3. Brogueira, P., Chu, V. and Conde, J.P. inAmorphous and Microcrystalline Silicon Technology, edited by Hack, M., Schiff, E.A., Madan, A., Powell, M. and Matsuda, A. (Mat. Res. Soc. Symp. Proc. 377, 1995) pp.57–62.Google Scholar
4. Conde, J.P., Brogueira, P., Castanha, R. and Chu, V., in Amorphous Silicon Technology, edited by Hack, M., Schiff, E.A., Wagner, S., Schropp, R. and Matsuda, A. (Mat. Res. Soc. Symp. Proc. 420, 1996), pp.357–362.Google Scholar
5. Diehl, F., Herbst, W., Schroder, B. and Oechsner, H. in Amorphous Silicon Technology, edited by Wagner, S., Hack, M., Schiff, E.A., Schropp, R. and Shimizu, I. (Mat. Res. Soc. Symp. Proc. 467, 1997) pp.451–456.Google Scholar
6. Wanka, H.N., Zedlitz, R., Heintze, M. and Schubert, M.B. in Amorphous Silicon Technology, edited by Hack, M., Schiff, E.A., Wagner, S., and Schropp, R. (Mat. Res. Soc. Symp. Proc. 420, 1996) pp.295–300.Google Scholar
7. Klug, H.P. and Alexander, L.E., X-ray Diffraction Procedure (Wiley, New York, 1974).Google Scholar
8. Yue, Guozhen, Lorentzen, J.D., Lin, Jing, Han, Daxing and Wang, Qi, submitted to APL.Google Scholar
9. Veprek, S., Sarott, F.A., and Iqbal, Z., Phys. Rev. B36, 3344 (1987).Google Scholar
10. Bustarret, E., Hachicha, M.A., and Brunel, M., Appl. Phys. Lett. 52, 1675 (1988).Google Scholar
11. Han, Daxing, Wang, Keda and Yang, Liyou, J. Appl. Phys. 80, 2475 (1996).Google Scholar
12. Anderson, D.A., Moddel, G., Collins, R.W. and Paul, W., Solid State Commun. 31, 677 (1979).Google Scholar
13. Bhat, P.K., Diprose, G., Searle, T.M., Austin, I.G., LeComber, P.G. and Spear, W.E., Physica 117B&118B, 917 (1983).Google Scholar
14. Savchouk, A.U., Ostapenko, S., Nowak, G., Lagowski, J., and Jastrzebski, L., Appl. Phys. Lett. 67, 82 (1995).Google Scholar