Hostname: page-component-586b7cd67f-t7czq Total loading time: 0 Render date: 2024-11-25T17:29:43.316Z Has data issue: false hasContentIssue false
  • English
  • Français

The Kinetics of Ni-Al Spinel Growth Using Rutherford Backscattering Spectroscopy

Published online by Cambridge University Press:  25 February 2011

Y. Kouh Simpson ,
E. G. Colgan  and
C. B. Carter
Y. Kouh Simpson
Affiliation:
Materials Science and Engineering, Cornell University, Ithaca, N.Y. 14853.
E. G. Colgan
Affiliation:
Materials Science and Engineering, Cornell University, Ithaca, N.Y. 14853.
C. B. Carter
Affiliation:
Materials Science and Engineering, Cornell University, Ithaca, N.Y. 14853.
Get access

Abstract

Using a planar thin-film specimen geometry, the growth kinetics of the spinel in NiOAl2O3 system has been studied with Rutherford backscattering spectroscopy. A thin-layer of Ni film is deposited by the electron-beam deposition technique onto single-crystal alumina substrates of different orientations including, (0001), {1120}, {1102} and {1100}. The subsequent heat-treatment in air then converts the Ni to NiO, thus producing a uniform layer of NiO with good adhesion between the NiO and the alumina. The kinetics of the Ni-Al spinel growth has been found to be different for different single-crystal substrate orientations. The kinetics behavior follows a parabolic growth-rate law for each orientation but shows a different reaction-rate constant. X-ray diffraction and transmission electron microscopy have been used as complementary techniques to confirm the phases that form at each stage of the heat treatment and the corresponding microstructures of the thin-film layers respectively.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 94: Symposium D – Initial Stages of Epitaxial Growth , 1987 , 299
Copyright
Copyright © Materials Research Society 1987

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1. Pettit, F.S., Randklev, E.H. and Felten, E.J., J. Am. Ceram. Soc., 49, 199–203 (1966).CrossRefGoogle Scholar
2. Lindner, R. and Åkerström, Å., Z. Phys. Chem. (Frankfurt am Main), 18, 303–307 (1958).Google Scholar
3. Hirota, K. and Komatsu, W., J. Am Ceram. Soc., 60, 105–107 (1977).CrossRefGoogle Scholar
4. Minford, W.J. and Stubican, V.S., J. Am. Ceram. Soc., 57, 363–367 (1974).Google Scholar
5. Simpson, Y. Kouh and Carter, C.B., Phil. Mag. A53 [1], L1–L6 (1986).Google Scholar
6. Simpson, Y. Kouh and Carter, C.B., Mat. Res. Soc. Symp. Proc. 60, 265–272 (1986).Google Scholar
7. Simpson, Y. Kouh and Carter, C. B., Mat. Res. Soc. Symp. Proc. 1987, Anaheim, these proceedings.Google Scholar
8. Roos, G. de, Wit, J.H.W. de, Fluit, J.M., Gew, J.W. and Velthuizen, R.P., Sruface and Interface Anal., 5 [3], 119–131 (1983).Google Scholar
9. Roos, G. de, Fluit, J.M., Wit, J.H.W. de and Geus, J.W., Surface and Interface Anal.,3 [5], 229–234 (1981).Google Scholar
10. Roos, G. de, Fluit, J.M., Wit, J.H.W. de and Geus, J.W., Solid State Chemistry, Proc. 2nd. Europ. Conf., Studies in Inorganic Chemistry. 3. edited by Metselaar, R., Heijlingers, H.J.M. and Schoonman, J., 423–426 (1982).Google Scholar
11. Roos, G. de, Wit, J.H.W. de, Fluit, J.M. and Geus, J.W., Surface and Interface Anal., 5 [4], 167–169 (1983).Google Scholar
12. Roos, G. de, Geus, J.W., Fluit, J.M. and Wit, J.H. de, Nucl. Inst. and Meth., 168, 485–489 (1980).CrossRefGoogle Scholar
13. Simpson, Y. Kouh, Colgan, E.G. and Carter, C. B., J. Am. Ceram. Soc. in press (1987).Google Scholar
14. Chu, W-K., Mayer, J.W. and Nicolet, M-A., Backscattering Spectrometry (Academic Press), (1978).Google Scholar
15. Doolittle, L.R., Nucl. Inst. Meth., B9, 344–351 (1985).CrossRefGoogle Scholar
16. Ziegler, J.F., Biersack, J.P., and Littmark, U., IBM Research Report RC9250 (1982).Google Scholar
17. Simpson, Y. Kouh, Colgan, E.G. and Carter, C. B., Unpublished Work.Google Scholar