Hostname: page-component-586b7cd67f-l7hp2 Total loading time: 0 Render date: 2024-11-25T17:29:45.122Z Has data issue: false hasContentIssue false
  • English
  • Français

Spin-on Silicon Oxide (SOX): Physical Properties of the Sol

Published online by Cambridge University Press:  25 February 2011

Vivian Ryan  and
Gerald Smolinsky
Vivian Ryan
Affiliation:
AT&T Bell Laboratories, Murray Hill, NJ 07974–2070
Gerald Smolinsky
Affiliation:
AT&T Bell Laboratories, Murray Hill, NJ 07974–2070
Get access

Abstract

This paper describes an analysis of the physical properties of the sol using several complementary light scattering techniques. Polymerization and aggregation kinetics were followed through time-dependent changes in the size, shape, and density of the sol particles. The sot growth rate was controlled by choice of solvent and silicon concentration. Changes in viscosity and pH were small during the reaction period. Three different particle-growth regimes exist in which either the particle density increased, decreased, or remained the same. The addition of boron, hydrofluoric acid, or water accelerated the reaction. The sol experimental data correlate with the density and wet-etching rate of the cured films. After curing, high-density films were obtained from sols with three common characteristics: an average particle diameter >450 Å, a relatively high polydispersity, and a low particle density. These criteria were generally satisfied by solutions one to two days old.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 131: Symposium E – Chemical Perspectives of Microelectronic Materials I , 1988 , 569
Copyright
Copyright © Materials Research Society 1989

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

[1] Smolinsky, G. and Ryan, V., in “Chemical Perspectives of Microelectronic Materials,” edited by Gross, M.E., Yates, J.T. Jr, and Jasinski, J. (Mater. Res. Soc. Proc., 131, Pittsburgh, PA 1989) this issue.Google Scholar
[2] Debye, P., J. Phys. Chem., 51, 18 (1947).Google Scholar
[3] Kerker, M., The Scattering of Light and Other Electromagnetic Radiation; Academic Press: New York, 1969; p. 427.Google Scholar
[4] Berne, B.J. and Pecora, F., Dynamic Light Scattering; John Wiley & Sons, Inc.: New York, 1976; p. 174.Google Scholar
[5] Chandrasekhar, S., Rev. Modern Phys., 15, No. 1 (1943).Google Scholar
[6] Oster, G., J. Colloid Sci., 2, 291 (1947).Google Scholar
[7] Brice, B.A., Halwer, M., and Speiser, R., J. Opt. Soc. Am., 40, 768 (1950).Google Scholar
[8] Tomimatsu, Y. and Palmer, K.J., J. Phys. Chem., 67, 1720 (1963).Google Scholar
[9] Heymann, E., Trans. Faraday Soc., 32, 462 (1936).Google Scholar
[10] Bates, R.G., Determination of pH: Theory and Practice; John Wiley & Sons, Inc.: New York, 1954; Chapter 8.Google Scholar
[11] Brinker, C.J., Keefer, K.D., Schaefer, D.W., and Asley, C.S., J. Non-Crystalline Solids, 48, 47 (1982).Google Scholar