Hostname: page-component-586b7cd67f-dlnhk Total loading time: 0 Render date: 2024-11-25T17:30:26.574Z Has data issue: false hasContentIssue false
  • English
  • Français

Properties of High Conductivity Phosphorous Doped Hydrogenated Microcrystalline Silicon and Application in Thin Film Transistor Technology

Published online by Cambridge University Press:  25 February 2011

J. Kanicki ,
E. Hasan ,
J. Griffith ,
T. Takamori  and
J. C. Tsang
J. Kanicki
Affiliation:
IBM Research Division, Thomas J. Watson Research Center, P.O. Box 218, Yorktown Heights, New York 10598
E. Hasan
Affiliation:
Department of Materials Science and Engineering, MIT, Cambridge, MA 02139
J. Griffith
Affiliation:
IBM Research Division, Thomas J. Watson Research Center, P.O. Box 218, Yorktown Heights, New York 10598
T. Takamori
Affiliation:
IBM Research Division, Thomas J. Watson Research Center, P.O. Box 218, Yorktown Heights, New York 10598
J. C. Tsang
Affiliation:
IBM Research Division, Thomas J. Watson Research Center, P.O. Box 218, Yorktown Heights, New York 10598
Get access

Abstract

Device quality phosphorous (P) doped hydrogenated microcrystalline silicon (n+μc - Si:H) has been prepared by using the plasma enhanced chemical vapor deposition technique. The dependence of physical, chemical, structural and electrical properties on substrate temperature have been investigated. Conductivities for thick films up to 12 Ω−lcm−1 and 40 Ω−1cm−1 have been achieved for layers deposited at 300°C and 500°C, respectively. For films 50 nm thick deposited at 300°C a conductivity of about 5 Ω−1cm−1 has been obtained. A maximum average grain size around 30 nm was obtained. The etch rates of P-doped microcrystalline silicon have been found to be between 8 and 10 times higher than that of undoped hydrogenated amorphous silicon (a-Si:H) films deposited at the same temperature. Thin film transistors incorporating heavily P-doped amorphous and microcrystalline layer between source/drain metal and the a-Si:H channel have been fabricated. We show that an n+μc - Si:H source/drain contacts in thin film transistors provides very good characteristics, yielding an average effective field effect mobility, threshold voltage, and on/off current ratio of about 0.9cm2V−1 sec−1, below 4 V, and above 107, respectively.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 149: Symposium E – Amorphous Silicon Technology - 1989 , 1989 , 239
Copyright
Copyright © Materials Research Society 1989

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1. Powell, M.J., Mat. Res. Soc. Symp. Proc., 33, 259 (1984).CrossRefGoogle Scholar
2. Chikamura, T., Hotta, S. and Nagata, S., Mat. Res. Soc. Symp. Proc., 95, 421 (1987).Google Scholar
3. Lustig, N. and Kanicki, J., J. Appl. Phys., 65, 3951 (1989).Google Scholar
4. Kanicki, J., Appl. Phys. Lett., 53, 1943 (1988).Google Scholar
5. Tuan, H.C., Mat. Res. Soc. Proc., 33, 247 (1984).Google Scholar
6. Manookian, W.Z. and Wilson, J.I.B., IEEE Proc., 133, 153 (1986).Google Scholar
7. Uchida, Y., Ichimura, T., Ueno, M. and Ohsawa, M., J. de Phys. 42, C4–265 (1981).Google Scholar
8. Usui, S. and Kikuchi, M., J. Non-Crystalline Solids, 34, 1 (1979).Google Scholar
9. Matsuda, A., Yamasaki, S., Nakagawa, K., Okushi, H., Tanaka, K., lizima, S., Matsumara, M. and Yamamoto, H., Jap. J. Appl. Phys., 19, L305 (1980).Google Scholar
10. Hamasaki, T., Kurata, H., Hirose, M. and Osaka, Y., Appl. Phys. Lett., 37, 1084 (1980).Google Scholar
11. Mishima, Y., Hamasaki, T., Kurata, H., Hirose, M. and Osaka, Y., Jap. J. Appl. Phys 20, L121 (1981).Google Scholar
12. Hasegawa, S., Narikawa, S. and Kurata, Y., Philos. Mag. B, 48, 431 (1983).Google Scholar
13. Spear, W.E., Willeke, G. and LeComber, P.G., Physica, 117B & 118B, 908 (1983).Google Scholar
14. Azaroff, L.V., “Elements of X-ray Crystallography,” p.556, McGraw-Hill, New York (1968); B.E. Warren, “X-ray Diffraction,” p. 257, Addison-Wesley, Reading, MA (1969); and B.D. Cullity, “Elements of X-ray Diffraction,” p. 99, Addison-Wesley, Reading, MA (1967)Google Scholar
15. Iqbal, Z. and Veprek, S., J. Phys. C: Solid State Phys., 15, 377 (1982).CrossRefGoogle Scholar