Hostname: page-component-78c5997874-fbnjt Total loading time: 0 Render date: 2024-11-09T12:46:25.310Z Has data issue: false hasContentIssue false
  • English
  • Français

Energy Resolved Mass Spectrometry of the a-Si:D Film Growth Species During DC Magnetron Sputtering

Published online by Cambridge University Press:  25 February 2011

A. M. Myers ,
D. N. Ruzic ,
N. Maley ,
J. R. Doyle  and
J. R. Abelson
A. M. Myers
Affiliation:
Coordinated Science Laboratory and Dept. of Materials Science and Engineering, University of Illinois, 1101 W. Springfield, Urbana, IL. 61801.
D. N. Ruzic
Affiliation:
Coordinated Science Laboratory and Dept. of Materials Science and Engineering, University of Illinois, 1101 W. Springfield, Urbana, IL. 61801.
N. Maley
Affiliation:
Coordinated Science Laboratory and Dept. of Materials Science and Engineering, University of Illinois, 1101 W. Springfield, Urbana, IL. 61801.
J. R. Doyle
Affiliation:
Coordinated Science Laboratory and Dept. of Materials Science and Engineering, University of Illinois, 1101 W. Springfield, Urbana, IL. 61801.
J. R. Abelson
Affiliation:
Coordinated Science Laboratory and Dept. of Materials Science and Engineering, University of Illinois, 1101 W. Springfield, Urbana, IL. 61801.
Get access

Abstract

Double modulated beam mass spectrometry was used to obtain the first measurements of the identity, relative flux, and energy of film precursors in reactive dc magnetron sputtering. In these experiments, a 2″ diameter silicon target was sputtered in an argon plus deuterium plasma at an argon pressure of 1.5 mTorr. This system produces high quality a-Si:D. Energetic neutral Si and SiD were observed, while energetic neutral SiD2 and SiD3 were absent. The arrival rate of D in the form of SiD increased and then saturated at 19 percent of the total flux as the deuterium pressure was varied from 0 to 5 mTorr. The sputtered Si energy agreed qualitatively with the standard Thompson theory. Energetic ions located at mass 2 and 4 were measured with energies much greater than the sputtered Si. Thermal silane was also detected, raising the possibility that thermal silane radicals in addition to energetic Si and SiD contribute to film growth.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 192: Symposium O – Amorphous Silicon Technology - 1990 , 1990 , 595
Copyright
Copyright © Materials Research Society 1990

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

Robertson, R. and Gallagher, A., J. Appl. Phys. 59, 3402 (1986).Google Scholar
2. Tsai, C.C., Knights, J.C., Chang, G., and Wacker, B., J. Appl. Phys. 59, 2998 (1986).Google Scholar
3. Moustakas, T.D., in Semiconductors and Semimetals Vol. 21 Part A Hydrogenated Amorphous Silicon, edited by Pankove, Jacques I.(Academic Press, Orlando Florida, 1984), p.55.Google Scholar
4. Thornton, J.A. and Hoffman, D.W., Thin Solid Films 171, 5 (1989).Google Scholar
5. Tardy, D.J., Poitevin, J.M., Lemperiere, G., J. Phys. D 14, 339 (1981).Google Scholar
6. Matsuda, A., Nakagawa, K., Tanaka, K., Matsumara, M., Yamasaki, S., Okushi, H., and Iizima, S., J. Non-Cryst Solids 35–36, 183 (1980).Google Scholar
7. Myers, A.M., Ruzic, D.N., Powell, R.C., Maley, N., Pratt, D.W., Greene, J.E., and Abelson, J.R., J. Vac. Sci. Technol. A. in press.Google Scholar
8. Myers, A.M., Ruzic, D.N., Doyle, J.R., Maley, N., and Abelson, J.R., to be published.Google Scholar
9. Abelson, J.R., Doyle, J.R., Mandrell, L., Myers, A.M., and Maley, N., J. Vac. Sci .Technol. A., in press.Google Scholar
10. Yehoda, J.E., Yang, B., Vedam, K., Messier, R., J. Vac. Sci. Technol. A6, 1631 (1988).Google Scholar
11. Sigmund, P., in Sputtering by Particle Bombardment I, edited by Behrisch, R. (Springer Verlag, New York, 1981), p. 9.Google Scholar
12. CRC Handbook of Chemistry and Physics, 60th ed. (CRC Press, Boca Raton Florida, 1979), p. D-75.Google Scholar