Hostname: page-component-586b7cd67f-t7czq Total loading time: 0 Render date: 2024-11-20T06:29:10.306Z Has data issue: false hasContentIssue false
  • English
  • Français

Formation of LuFe2O4 phase from an undercooled LuFeO3 melt in reduced oxygen partial pressure

Published online by Cambridge University Press:  31 January 2011

M.S. Vijaya Kumar ,
Kazuhiko Kuribayashi  and
Koichi Kitazono
M.S. Vijaya Kumar*
Affiliation:
Department of Aerospace Engineering, Tokyo Metropolitan University, Hino, Tokyo 191-0065, Japan; and Institute of Space and Astronautical Science (ISAS), Japan Aerospace Exploration Agency (JAXA), Sagamihara, Kanagawa 229-8510, Japan
Kazuhiko Kuribayashi
Affiliation:
Institute of Space and Astronautical Science (ISAS), Japan Aerospace Exploration Agency (JAXA), Sagamihara, Kanagawa 229-8510, Japan
Koichi Kitazono
Affiliation:
Department of Aerospace Engineering, Tokyo Metropolitan University, Hino, Tokyo 191-0065, Japan
*
a)Address all correspondence to this author. e-mail: [email protected]
Get access

Abstract

The formation of metastable phases from an undercooled LuFeO3 melt was investigated under reduced Po2 since the iron ion has the tendency to change its valence state from Fe3+ to Fe2+ in an ambient atmosphere with low Po2. The nucleation and the post-recalescence temperatures of the phases were decreased with decreasing process Po2. Phase equilibrium was established in the Lu–Fe–O system at 1473 K by varying the oxygen partial pressure from 105 to 10−1 Pa. A possible ternary metastable phase diagram depending on the oxygen composition in the bulk sample was also constructed. The formation of the LuFe2O4 phase where the Fe3+ and Fe2+ ratio is 1:1 clearly indicated that the formation of metastable phases is related to the presence of Fe2+ ions. Thermogravimetric analysis revealed that the increase in sample mass with decreasing process Po2, down to 10−1 Pa, is relatively dependent on the amount of Fe2+ ions.

Keywords

LuPhase equilibriaRapid solidification
Type
Articles
Information
Journal of Materials Research , Volume 23 , Issue 11 , November 2008 , pp. 2996 - 3005
Copyright
Copyright © Materials Research Society 2008

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1Kumar, M.S. Vijaya, Nagashio, K., Hibiya, T., Kuribayashi, K.: Formation of hexagonal metastable phases from an undercooled LuFeO3 melt in an atmosphere with low oxygen partial pressure. J. Am. Ceram. Soc. 91, 806 2008CrossRefGoogle Scholar
2Herlach, D.M.: Non-equilibrium solidification of undercooled metallic melts. Mater. Sci. Eng., R 12, 177 1994CrossRefGoogle Scholar
3Feuerbacher, B.: Phase formation in metastable solidification of metals. Mater. Sci. Rep. 4, 1 1989CrossRefGoogle Scholar
4Turnbull, D.: Undercoolability and the exposure of metastable structures in Undercooled Alloy Phases, edited by E.W. Collings and C.C. Koch (The Metallurgical Soc. Hume-Rothery Memorial Symp. Proc., Warrendale, PA, 1986), p. 3Google Scholar
5Badets, M.C., Bessada, C., Simon, P., Billard, D., Massiot, A., Massiot, D., Rifflet, J.C., Taulelle, F., Coutures, J.P.: Material processing and characterization of Y3Al5O12 and CaAl2O4 glasses obtained under contactless conditions in Materials and Fluid Science in Microgravity, edited by B.H. Kaldeich, VIIth European Symp. Proc., Oxford, UK, (European Space Agency, Paris, France, 1989), Vol. ESA SP-295, p. 511Google Scholar
6Babin, F., Gagne, J.M., Paradis, P.F., Coutures, J.P., Rifflet, J.C.: High temperature containerless laser processing of dielectric samples in microgravity. Microgravity Sci. Technol. 7, 283 1995Google Scholar
7Yu, J., Arai, Y., Koshikawa, N., Ishikawa, T., Yoda, S.: Containerless solidification of BiFeO3 oxide under microgravity Materials Research in Low Gravity II,, edited by N. Ramachandran (The International Society for Optical Engineering, Bellingham, WA, 1999), Vol. 3792, p. 226CrossRefGoogle Scholar
8Glorieux, B., Saboungi, M.L., Millot, F., Enderby, J., Rifflet, J.C.Aerodynamic levitation: An approach to microgravity. AIP Conf. Proc 552, 316 2001CrossRefGoogle Scholar
9Nagashio, K., Yamaguchi, O., Hibiya, T., Kuribayashi, K.: Formation of metastable rare-earth garnet by splat quenching. J. Am. Ceram. Soc 89, 1504 2006CrossRefGoogle Scholar
10Kuribayashi, K., Nagashio, K., Niwata, K., Kumar, M.S. Vijaya, Hibiya, T.: Novel criterion for formation of metastable phase from undercooled melt. Mater. Sci. Eng., A 449–451, 675 2007CrossRefGoogle Scholar
11Kuribayashi, K., Ozawa, S.: Metastable phase formation from undercooled melt of Nd–Fe–B alloys. J. Alloys Compd. 408–412, 266 2006CrossRefGoogle Scholar
12Nagashio, K., Kuribayashi, K.: Metastable phase formation from an undercooled rare-earth orthoferrite melt. J. Am. Ceram. Soc. 85, 2550 2002CrossRefGoogle Scholar
13Goldschmidt, V.M. Geochemical distribution laws of elements VII. (Die Gesetze der Krystallochemie. Math-Naturv. K1. Oslo, Norway, 1926), p. 97Google Scholar
14Shannon, R.D.: Revised effective ionic radii and systematic studies of interatomic distances on halides and chalcogenides. Acta Crystallogr. A 32, 751 1976CrossRefGoogle Scholar
15Sekine, T., Katsura, T.: Phase equilibria in the system Fe– Fe2O3–Lu2O3 at 1200 °C. J. Solid State Chem. 17, 49 1976CrossRefGoogle Scholar
16Ikeda, N., Ohsumi, H., Ohwada, K., Ishii, K., Inami, T., Kakurai, K., Murakami, Y., Yoshii, K., Mori, S., Horibe, Y., Kito, H.: Ferroelectricity from iron valence ordering in the charge-frustrated system LuFe2O4. Nature 436, 1136 2005CrossRefGoogle ScholarPubMed
17Kimizuka, N., Yamamoto, A., Ohashi, H., Sugihara, T., Sekine, T.: The stability of the phases in the Ln2O3–FeO–Fe2O3 systems which are stable at elevated temperatures (Ln: lanthanide elements and Y). J. Solid State Chem. 49, 65 1983CrossRefGoogle Scholar
18Katsura, T., Sekine, T., Kitayama, K., Sugihara, T., Kimizuka, N.: Thermodynamic properties of Fe-lanthanoid-O compounds at high temperatures. J. Solid State Chem. 23, 43 1978CrossRefGoogle Scholar