Hostname: page-component-cd9895bd7-gxg78 Total loading time: 0 Render date: 2024-12-23T11:56:08.008Z Has data issue: false hasContentIssue false
  • English
  • Français

Enhancement of solar cells with photonic and plasmonic crystals - overcoming the Lambertian limit

Published online by Cambridge University Press:  03 April 2013

Rana Biswas ,
Sambit Pattnaik ,
Chun Xu ,
Joydeep Bhattacharya ,
Nayan Chakravarty  and
Vikram Dalal
Rana Biswas*
Affiliation:
Department of Physics and Astronomy and Ames Laboratory, Iowa State University, Ames, Iowa 50011; and Microelectronics Research Center and Department of Electrical and Computer Engineering, Iowa State University, Ames, Iowa 50011
Sambit Pattnaik
Affiliation:
Microelectronics Research Center and Department of Electrical and Computer Engineering, Iowa State University, Ames, Iowa 50011
Chun Xu
Affiliation:
Department of Physics and Astronomy and Ames Laboratory, Iowa State University, Ames, Iowa 50011
Joydeep Bhattacharya
Affiliation:
Microelectronics Research Center and Department of Electrical and Computer Engineering, Iowa State University, Ames, Iowa 50011
Nayan Chakravarty
Affiliation:
Microelectronics Research Center and Department of Electrical and Computer Engineering, Iowa State University, Ames, Iowa 50011
Vikram Dalal
Affiliation:
Microelectronics Research Center and Department of Electrical and Computer Engineering, Iowa State University, Ames, Iowa 50011
*
a)Address all correspondence to this author. e-mail: [email protected]
Get access

Abstract

Red and near-infrared photons of longer wave lengths are poorly absorbed in thin film silicon cells and advanced light trapping methods are necessary. The physical mechanisms underlying the light trapping using periodic back reflectors are strong light diffraction, coupled with plasmonic light concentration. These are contrasted with the scattering mechanisms in randomly textured back reflectors. We describe a class of conformal solar cells with nanocone back reflectors with absorption at the Lambertian 4n2 limit, averaged over the “entire” wave length range for hydrogenated nanocrystalline silicon (nc-Si:H) thin-film solar cells. The absorption is theoretically found for 1-μm nc-Si:H cells, and is further enhanced for off-normal incidence. Predicted currents exceed 31 mA/cm2. Nc-Si:H solar cells with the same device architecture were conformally grown on periodic substrates and compared with randomly textured substrates. The periodic back reflector solar cells with nanopillars demonstrated higher quantum efficiency and photocurrents that were 1 mA/cm2 higher than those for the randomly textured back reflectors.

Type
Invited Feature Papers
Information
Journal of Materials Research , Volume 28 , Issue 8 , 28 April 2013 , pp. 1021 - 1030
Copyright
Copyright © Materials Research Society 2013

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

Dionne, J.A. and Atwater, H.A.: Plasmonics: Metal-worthy methods and materials in nanophotonics. MRS Bull. 37, 717 (2012).Google Scholar
Schropp, R.E.I. and Zeman, M.: Amorphous and Microcrystalline Silicon Solar Cells: Modeling, Materials, and Device Technology (Kluwer Academic, Boston, MA, 1998).Google Scholar
Shah, A.V., Schade, H., Vanecek, M., Meier, J., Vallat-Sauvain, E., Wyrsch, N., Kroll, U., Droz, C., and Bailat, J.: Thin-film silicon solar cell technology. Prog. Photovoltaics Res. Appl. 12:113–142 (2004).Google Scholar
Yue, G.Z., Sivec, L., Owens, J.M., Yan, B.J., Yang, J., and Guha, S.: Optimization of back reflector for high efficiency hydrogenated nanocrystalline silicon solar cells. Appl. Phys. Lett. 95, 263501 (2009).Google Scholar
Battaglia, C., Escarre, J., Soderstrom, K., Erni, L., Ding, L., Bugnon, G., Billet, A., Boccard, M., Barraud, L., DeWolf, S., Haug, F.J., Despeisse, M., and Ballif, C.: Nanoimprint lithography for high-efficiency thin-film silicon solar cells. Nano Lett. 11, 661 (2011).Google Scholar
Yue, G.Z., Sivec, L., Yan, B., Yang, J., and Guha, S.: High efficiency hydrogenated nanocrystalline silicon solar cells deposited at high rates. In Amorphous and Polycrystalline Thin-Film Silicon Science and Technology–2010, edited by Wang, Q., Yan, B., Flewitt, A., Tsai, C-C., and Higashi, S. (Mater. Res. Soc. Symp. 1245, Warrendale, PA, 2010), p. 441. 1245-A21-01.Google Scholar
Isabella, O., Krc, J., and Zeman, M.: Modulated surface textures for enhanced light trapping in thin-film silicon solar cells. Appl. Phys. Lett. 97, 101106 (2010).Google Scholar
Battaglia, C., Escarré, J., Soderstrom, K., Charrière, M., Despeisse, M., Haug, F-J., and Ballif, C.: Nanomoulding of transparent zinc oxide electrodes for efficient light trapping in solar cells. Nat. Photonics 5, 535 (2011).Google Scholar
Ferry, V.E., Verschuuren, M.A., Li, H.B.T., Walters, R.J., Schropp, R.E.I., Atwater, H.A., and Polman, A.: Light trapping in ultrathin plasmonic solar cells. Opt. Exp. 18, A237–A245 (2010).Google Scholar
Sai, H. and Kondo, M.: Effect of self-orderly textured back reflectors on light trapping in thin-film microcrystalline silicon solar cells. J. Appl. Phys. 105, 094511 (2009).Google Scholar
Curtin, B., Biswas, R., and Dalal, V.: Photonic crystal based back reflectors for light management and enhanced absorption in amorphous silicon solar cells. Appl. Phys. Lett. 95, 231102 (2009).Google Scholar
Bhattacharya, J., Chakravarty, N., Pattnaik, S., Slafer, W.D., Biswas, R., and Dalal, V.L.: A novel photonic-plasmonic structure for enhancing light absorption in thin film solar cells. Appl. Phys. Lett. 99, 131114 (2011).CrossRefGoogle Scholar
Ferry, V.E., Verschuuren, M.A., Li, H.B.T., Schropp, R.E.I., Atwater, H.A., and Polman, A.: Improved red-response in thin film a-Si:H solar cells with soft-imprinted plasmonic back reflectors. Appl. Phys. Lett. 95, 183503 (2009).Google Scholar
Ferry, V.E., Verschuuren, M.A., van Lare, M.C., Schropp, R.E.I., Atwater, H.A., and Polman, A.: Optimized spatial correlations for broadband light trapping nanopatterns in high efficiency ultrathin film a-Si:H solar cells. Nano Lett. 11, 4239 (2011).Google Scholar
Gusak, V., Kasemo, B., and Hagglund, C.: Thickness dependence of plasmonic carrier generation in ultra thin a-Si:H layers for solar cells. ACS Nano 8, 6218 (2011).Google Scholar
Tan, H., Santbergen, R., Smets, A.H.M., and Zeman, M.: Plasmonic light trapping in thin-film silicon solar cells with improved self-assembled silver nanoparticles. Nano Lett. 12, 4070 (2012).Google Scholar
Yablonovitch, E.: Statistical ray optics. J. Opt. Soc. Am. 72, 899–907 (1982).Google Scholar
Tiedje, T., Yablonovitch, E., Cody, G.D., and Brooks, B.: Limiting efficiency of silicon solar cells. IEEE Trans. Electron Devices 31, 711–716 (1984).Google Scholar
Schiff, E.A.: Thermodynamic limit to photonic-plasmonic light-trapping in thin films on metals. J. Appl. Phys. 110, 104501 (2011).Google Scholar
Biswas, R. and Xu, C.: Nano-crystalline silicon solar cell architecture with absorption at the classical 4n2 limit. Opt. Exp. 19, A664 (2011).CrossRefGoogle ScholarPubMed
Yu, Z., Raman, A., and Fan, S.: Fundamental limit of nanophotonic light trapping in solar cells. Proc. Nat. Acad. Sci. 107(41), 17491–17496 (2010).CrossRefGoogle ScholarPubMed
Springer, J., Poruba, A., Mullerova, L., Vanecek, M., Kluth, O., and Rech, B.: Absorption loss at nanorough silver back reflector of thin-film silicon solar cells. J. Appl. Phys. 95, 1427 (2004).CrossRefGoogle Scholar
Zhou, D. and Biswas, R.: Photonic crystal enhanced light-trapping in thin film solar cells. J. Appl. Phys. 103, 093102 (2008).Google Scholar
Bermel, P., Luo, C., Zeng, L., Kimerling, L.C., and Joannopoulos, J.: Improving solar cell efficiencies with photonic crystals. Opt. Exp. 15, 16986 (2007).Google Scholar
Atwater, H. and Polman, A.: Plasmonics for improved photovoltaic devices. Nat. Photonics 9, 205 (2010).Google Scholar
Pillai, S., Catchpole, K.R., Trupke, T., and Green, M.A.: Surface plasmon enhanced solar cells. J. Appl. Phys. 101(9), 093105 (2007).Google Scholar
Dahal, L.R., Sainju, D., Li, J., Stoke, J.A., Podraza, N., Deng, X., and Collins, R.W.: Plasmonic characteristics of Ag/ZnO back-reflectors for thin film Si photovoltaics. Proceedings 33rd IEEE Photovoltaic Specialists Conference, San Diego, CA, 2008. pp. 1–6.Google Scholar
Li, Z.Y. and Lin, L.L.: Photonic band structures by a plane-wave-based transfer matrix method. Phys. Rev. E 67, 046607 (2003).Google Scholar
Haug, F.J., Soderstrom, K., Naqavi, A., and Ballif, C.: Resonances and absorption enhancement in thin film silicon solar cells with periodic interface texture. J. Appl. Phys. 109, 084516 (2011).Google Scholar
Yue, G., Yan, B.J., Sivec, L., Su, T., Zhou, Y., Yang, J., and Guha, S.: Hydrogenated nanocrystalline silicon based solar cell with 13.6% stable efficiency. In Amorphous and Polycrystalline Thin-Film Silicon Science and Technology–2012, edited by Yan, B., Gleskova, H., Tsai, C-C., Sameshima, T., and Cohen, J.D. (Mater. Res. Soc. Symp. Proc. 1426, Warrendale, PA, 2012), pp. 33–38, doi: 10.1557/opl.2012.834.Google Scholar
Pattnaik, S., Chakravarty, N., Slafer, D., Biswas, R., and Dalal, V.: Light-trapping in thin film silicon solar cells with a combination of periodic and randomly textured back-reflectors. In Amorphous and Polycrystalline Thin-Film Silicon Science and Technology–2012, edited by Yan, B., Gleskova, H., Tsai, C-C., Sameshima, T., and Cohen, J.D. (Mater. Res. Soc. Symp. Proc. 1426, Warrendale, PA, 2012), pp. 117–123. doi: 10.1557/opl.2012.888. 11.Google Scholar