Hostname: page-component-586b7cd67f-t8hqh Total loading time: 0 Render date: 2024-11-27T01:02:25.244Z Has data issue: false hasContentIssue false
  • English
  • Français

Changes in structures and electrical conduction mechanisms of chemical vapor deposited Ta2O5 thin films by annealing under O3 atmosphere with ultraviolet light radiation

Published online by Cambridge University Press:  03 March 2011

Dail Eom ,
In Sang Jeon ,
Sang Yong No ,
Cheol Seong Hwang  and
Hyeong Joon Kim
Dail Eom
Affiliation:
School of Materials Science and Engineering, and Inter-university Semiconductor Research Center, Seoul National University, Seoul 151-742, Korea
In Sang Jeon
Affiliation:
School of Materials Science and Engineering, and Inter-university Semiconductor Research Center, Seoul National University, Seoul 151-742, Korea
Sang Yong No
Affiliation:
School of Materials Science and Engineering, and Inter-university Semiconductor Research Center, Seoul National University, Seoul 151-742, Korea
Cheol Seong Hwang*
Affiliation:
School of Materials Science and Engineering, and Inter-university Semiconductor Research Center, Seoul National University, Seoul 151-742, Korea
Hyeong Joon Kim
Affiliation:
School of Materials Science and Engineering, and Inter-university Semiconductor Research Center, Seoul National University, Seoul 151-742, Korea
*
a)Address all correspondence to these authors. a)e-mail: [email protected]
Get access

Abstract

The electrical conduction mechanisms of approximately 8-nm-thick Ta2O5 films grown by metalorganic chemical vapor deposition were investigated by measuring the current density–voltage characteristics at various temperatures. The Ta2O5 films were grown in two steps with or without intermittent annealing at 450 °C under an O3 atmosphere with ultraviolet light radiation (UV-O3 treatment). High-resolution transmission electron microscopy of the films after post-deposition annealing at 750 °C under an O2 atmosphere showed that the intermittent UV-O3 treatment improved the crystallization of the film during post-annealing. Auger electron spectroscopy of the variously treated samples showed that the improvement in crystallization was due to the increase in the oxygen concentration of the Ta2O5 films by the UV-O3 treatment. The Ta2O5 film without the UV-O3 treatment mostly exhibited a Poole–Frenkel conduction behavior with the electron trap level of 0.62 eV from the conduction band edge. The whole layer UV-O3 treated Ta2O5 films also showed a Poole–Frenkel conduction behavior with an almost identical electron trap level and a reduced density. The partially UV-O3 treated Ta2O5 films exhibited a direct tunneling behavior in a relatively low voltage region by the tunneling through the thin (∼3.8 nm) UV-O3 treated surface layer. However, these films showed a Poole–Frenkel conduction behavior in the high-voltage region. In general, the UV-O3 treatment was an efficient method to reduce the leakage current of the high-dielectric Ta2O5 films.

Keywords

Ta2O5 thin filmUV-O3 treatmentLeakage current
Type
Articles
Information
Journal of Materials Research , Volume 19 , Issue 5 , May 2004 , pp. 1516 - 1523
Copyright
Copyright © Materials Research Society 2004

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1Isobe, C. and Saitoh, M., Effect of ozone annealing on the dielectric properties of tantalum oxide thin films grown by chemical vapor deposition. Appl. Phys. Lett. 56, 907 (1990).CrossRefGoogle Scholar
2Ezhilvalavan, S. and Tseng, T-Y., Conduction mechanisms in amorphous and crystalline Ta2O5 thin films. J. Appl. Phys. 83, 4797 (1998).CrossRefGoogle Scholar
3 E. Atanassova, N. Novkovski, A. Paskaleva, and M. Pecovska-Gjorgjevich: Oxygen annealing modification of conduction mechanism in thin rf sputtered Ta2O5 on Si. Solid State Electron. (in press).Google Scholar
4Fang, Q., Zhang, J-Y., Wang, Z.M., Wu, J.X., O’Sullivan, B.J., Hurley, P.K., Leedham, T.L., Davies, H., Audier, M.A., Jimenez, C., Senateur, J-P. and Boyd, I.W., Interface of tantalum oxide films on silicon by UV annealing at low temperature. Thin Solid Films 428,248 (2003).CrossRefGoogle Scholar
5Shimizu, K., Katayama, M., Funaki, H., Arai, E., Nakata, M., Ohji, Y. and Imura, R., Stoichiometry measurement and electric characteristics of thin-film Ta2O5 insulator for ultra-large-scale integration. J. Appl. Phys. 74,375 (1993).CrossRefGoogle Scholar
6Houssa, M., Degraeve, R., Mertens, P.W., Heyns, M.M., Jeon, J.S., Halliyal, A. and Ogle, B., Electrical properties of thin SiON/Ta2O5 gate dielectric stacks. J. Appl. Phys. 86, 6462 (1999).CrossRefGoogle Scholar
7Chang, C.S., Liu, T.P. and Wu, T.B., Effects of postannealing on the electrical properties of Ta2O5 thin films deposited on TiN/T. J. Appl. Phys. 88, 7242 (2000).CrossRefGoogle Scholar
8Lee, J.S., Chang, S.J., Chen, J.F., Sun, S.C., Liu, C.H. and Liaw, U.H., Effects of O2 thermal annealing on the properties of CVD Ta2O5 thin films. Mater. Chem. Phys. 77,242 (2002).CrossRefGoogle Scholar
9Sze, S.M., Physics of Semiconductor Device (Wiley, New York, 1969)Google Scholar
10Yu, J.J., Zhang, J-Y. and Boyd, I.W., UV annealing of ultrathin tantalum oxide films. Appl. Surf. Sci. 186, 57 (2002).CrossRefGoogle Scholar
11Kao, K.C. and Hwang, H., Electrical transport in solid (Pergamon, Oxford, U.K., 1981), p. 314Google Scholar
12Chaneliere, C., Autran, J.L. and Devine, R.A.B., Conduction mechanisms in Ta2O5/SiO2 and Ta2O5/Si3N4 stacked structures on Si. J. Appl. Phys. 86, 480 (1999).CrossRefGoogle Scholar
13Yeo, Y.C., Lu, Q., Lee, W.C., King, T.J., Hu, C., Wang, W., Guo, X. and Ma, T.P., IEEE Electron Dev. Lett. 21, 540 (2000).Google Scholar
14Lai, B.C. and Lee, J.Y., Leakage Current Mechanism of Metal-Ta2O5-Metal Capacitors for Memory Device Applications. J. Electrochem. Soc. 146,266 (1999).CrossRefGoogle Scholar
15Blonkowski, S., Regache, M. and Halimaoui, A., Investigation and modeling of the electrical properties of metal-oxide-metal structures formed from chemical vapor deposited Ta2O5 films. J. Appl. Phys. 90,1501 (2001).CrossRefGoogle Scholar