Hostname: page-component-586b7cd67f-rcrh6 Total loading time: 0 Render date: 2024-11-26T18:25:52.705Z Has data issue: false hasContentIssue false
  • English
  • Français

Amorphization of nanocrystalline 3C-SiC irradiated with Si+ ions

Published online by Cambridge University Press:  31 January 2011

W. Jiang ,
H. Wang ,
I. Kim ,
Y. Zhang  and
W.J. Weber
W. Jiang*
Affiliation:
Pacific Northwest National Laboratory, Richland, Washington 99352
H. Wang
Affiliation:
Texas A&M University, College Station, Texas 77843
I. Kim
Affiliation:
Texas A&M University, College Station, Texas 77843
Y. Zhang
Affiliation:
Pacific Northwest National Laboratory, Richland, Washington 99352
W.J. Weber
Affiliation:
Department of Materials Science & Engineering, University of Tennessee, Knoxville, Tennessee 37996-2200; and Materials Science & Technology Division, Oak Ridge National Laboratory, Oak Ridge, Tennessee 37831-6138
*
a)Address all correspondence to this author. e-mail: [email protected]
Get access

Abstract

Irradiation-induced amorphization in nanocrystalline and single-crystal 3C-SiC has been studied using 1 MeV Si+ ions under identical irradiation conditions at room temperature and 400 K. The disordering behavior has been characterized using in situ ion channeling and ex situ x-ray diffraction methods. The results show that, compared with single-crystal 3C-SiC, full amorphization of small 3C-SiC grains (˜3.8 nm in size) at room temperature occurs at a slightly lower dose. Grain size decreases with increasing dose until a fully amorphized state is attained. The amorphization dose increases at 400 K relative to room temperature. However, at 400 K, the amorphization dose for 2.0 nm grains is about a factor of 4 and 8 smaller than for 3.0 nm grains and bulk single-crystal 3C-SiC, respectively. The behavior is attributed to the preferential amorphization at the interface.

Keywords

Ion-Solid InteractionsDefectsNanostructure
Type
Articles
Information
Journal of Materials Research , Volume 25 , Issue 12 , December 2010 , pp. 2341 - 2348
Copyright
Copyright © Materials Research Society 2010

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

Footnotes

b)

This author was an editor of this journal during the review and decision stage. For the JMR policy on review and publication of manuscripts authored by editors, please refer to http://www.mrs.org/jmr_policy

References

REFERENCES

1.Weber, W.J., Wang, L.M., Yu, N., Hess, N.J.: Structure and properties of ion-beam-modified (6H) silicon carbide. Mater. Sci. Eng., A 253, 62 (1998)Google Scholar
2.Jiang, W., Zhang, Y., Weber, W.J.: Temperature dependence of disorder accumulation and amorphization in Au-ion-irradiated 6H-SiC. Phys. Rev. B 70, 165208 (2004)CrossRefGoogle Scholar
3.Shen, T.D., Feng, S., Tang, M., Valdez, J.A., Wang, Y., Sickafus, K.E.: Enhanced radiation tolerance in nanocrystalline MgGa2O4. Appl. Phys. Lett. 90, 263115 (2007)CrossRefGoogle Scholar
4.Wang, H., Araujo, R., Swadener, J.G., Wang, Y.Q., Zhang, X., Fu, E.G., Cagin, T.: Ion irradiation effects in nanocrystalline TiN coatings. Nucl. Instrum. Methods Phys. Res., Sect. B 261, 1162 (2007)CrossRefGoogle Scholar
5.Jiang, W., Wang, H., Kim, I., Bae, I-T., Li, G., Nachimuthu, P., Zhu, Z., Zhang, Y., Weber, W.J.: Response of nanocrystalline 3C silicon carbide to heavy-ion irradiation. Phys. Rev B 80, 161301(R) (2009)CrossRefGoogle Scholar
6.Ziegler, J.F.: http://www.srim.orgGoogle Scholar
7.Devanathan, R., Weber, W.J., Gao, F.: Atomic scale simulation of defect production in irradiated 3C-SiC. J. Appl. Phys. 90, 2303 (2001)Google Scholar
8.Zhang, Y., Bae, I-T., Sun, K., Wang, C.M., Ishimaru, M., Zhu, Z., Jiang, W., Weber, W.J.: Damage profile and ion distribution of slow heavy ions in compounds. J. Appl. Phys. 105, 104901 (2009)Google Scholar
9.Weber, W.J., Yu, N., Wang, L.M.: Irradiation-induced amorphization in β-SiC. J. Nucl. Mater. 253, 53 (1998)CrossRefGoogle Scholar
10.Gao, F., Chen, D., Hu, W., Weber, W.J.: Energy dissipation and defect generation in nanocrystalline silicon carbide. Phys. Rev. B 81, 184101 (2010)CrossRefGoogle Scholar
11.Jiang, W., Weber, W.J., Lian, J., Kalkhoran, N.M.: Disorder accumulation and recovery in gold-ion irradiated 3C-SiC. J. Appl. Phys. 105, 013529 (2009)Google Scholar
12.Gao, F., Weber, W.J., Posselt, M., Belko, V.: Atomistic study of intrinsic defect migration in 3C-SiC. Phys. Rev. B 69, 245205 (2004)CrossRefGoogle Scholar
13.Rong, Z., Gao, F., Weber, W.J., Hobler, G.: Monte Carlo simulations of defect recovery within a 10 keV collision cascade in 3C-SiC. J. Appl. Phys. 102, 103508 (2007)CrossRefGoogle Scholar
14.Zhang, Y., Weber, W.J., Jiang, W., Wang, C.M., Shutthanandan, V., Hallén, A.: Effects of implantation temperature on damage accumulation in Al-implanted 4H–SiC. J. Appl. Phys. 95, 4012 (2004)CrossRefGoogle Scholar
15.Atwater, H.A., Brown, W.L.: Grain boundary mediated amorphization in silicon during ion irradiation. Appl. Phys. Lett. 56, 30 (1990)CrossRefGoogle Scholar
16.Atwater, H.A., Im, J.S., Brown, W.L.: Heterogeneous amorphization of Si during ion irradiation: Dependence of amorphous Si nucleation kinetics on defect energy and structure. Nucl. Instrum. Methods Phys. Res., Sect. B 59/60, 386 (1991)CrossRefGoogle Scholar
17.Jackson, K.A.: A defect model for ion-induced crystallization and amorphization. J. Mater. Res. 3, 1218 (1988)CrossRefGoogle Scholar
18.Kachurin, G.A., Ruault, M-O., Gutakovsky, A.K., Kaïtasov, O., Yanovskaya, S.G., Zhuravlev, K.S., Bernas, H.: Light particle irradiation effects in Si nanocrystals. Nucl. Instrum. Methods Phys. Res., Sect. B 147, 356 (1999)CrossRefGoogle Scholar
19.Shen, T.D.: Radiation tolerance in a nanostructure: Is smaller better? Nucl. Instrum. Methods Phys. Res., Sect. B 266, 921 (2008)Google Scholar