Hostname: page-component-78c5997874-94fs2 Total loading time: 0 Render date: 2024-11-06T10:54:41.022Z Has data issue: false hasContentIssue false
  • English
  • Français

Temporal analysis of capillary jet breakup

Published online by Cambridge University Press:  26 April 2006

N. Ashgriz  and
F. Mashayek
N. Ashgriz
Affiliation:
Department of Mechanical and Aerospace Engineering, State University of New York at Buffalo, Buffalo, NY 14260, USA
F. Mashayek
Affiliation:
Department of Mechanical and Aerospace Engineering, State University of New York at Buffalo, Buffalo, NY 14260, USA
Get access Rights & Permissions [Opens in a new window]

Abstract

The temporal instability of a cylindrical capillary jet is analysed numerically for different liquid Reynolds numbers Re, disturbance wavenumbers k, and amplitudes ε0. The breakup mechanism of viscous liquid jets and the formation of satellite drops are described. The results show that the satellite size decreases with decreasing Re, and increasing k and ε0. Marginal Reynolds numbers below which no satellite drops are formed are obtained for a large range of wavenumbers. The growth rates of the disturbances are calculated and compared with those from the linear theory. These results match for low-Re jets, however as Re is increased the results from the linear theory slightly overpredict those from the nonlinear analysis. (At the wavenumber of k = 0.9, the linear theory underpredicts the nonlinear results.) The breakup time is shown to decrease exponentially with increasing the amplitude of the disturbance. The cut-off wavenumber is shown to be strongly dependent on the amplitude of the initial disturbance for amplitudes larger than approximately $\frac13$ of the initial jet radius. The stable oscillations of liquid jets are also investigated. The results indicate that liquid jets with Re ∼ O(1) do not oscillate, and the disturbances are overdamped. However, liquid jets with higher Re oscillate with a period which depends on Re and ε0. The period of the oscillation decreases with increasing Re at small ε0; however, it increases with increasing Re at large ε0. Marginal Reynolds numbers below which the disturbances are overdamped are obtained for a wide range of wavenumbers and ε0 = 0.05.

Type
Research Article
Information
Journal of Fluid Mechanics , Volume 291 , 25 May 1995 , pp. 163 - 190
Copyright
© 1995 Cambridge University Press

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

Berger, S. A. 1988 Initial-value stability analysis of a liquid jet. SIAM J. Appl. Maths 48, 973–991.Google Scholar
Bidone, G. 1829 Experiences sur la forme et sur la direction des veines et des courants d'eau lances par diverses ouvertures. Imprimerie Royale, Turin, pp. 1–136.
Bogy, D. B. 1978a Use of one-dimensional Cosserat theory to study instability in a viscous liquid jet. Phys. Fluids 21, 190–197.Google Scholar
Bogy, D. B. 1978b Wave propagation and instability of a circular semi-infinite liquid jet harmonically forced at the nozzle. Trans. ASME E: J. Appl. Mech. 45, 469–474.Google Scholar
Bogy, D. B. 1979a Breakup of a liquid jet: Second perturbation solution for one-dimensional Cosserat theory. IBM J. Res. Dev. 23, 87–91.Google Scholar
Bogy, D. B. 1979b Drop formation in a circular jet. Ann. Rev. Fluid Mech. 11, 207–228.Google Scholar
Bousfield, D. W., Keunings, R., Marrucci, G. & Denn, M. M. 1986 Nonlinear analysis of the surface tension driven breakup of viscoelastic filaments. J. Non-Newtonian Fluid Mech. 21, 79–97.Google Scholar
Bousfield, D., Stockel, I. H. & Nanivadekar, C. K. 1990 The breakup of viscous jets with large velocity modulations. J. Fluid Mech. 218, 601–617.Google Scholar
Boussinesq, J. 1877 Mem. Acad. Sci. Paris 23, 639.
Caulk, D. A. 1976 Some two and one dimensional problems in fluid mechanics by a direct approach. PhD thesis, University of California, Berkeley.
Caulk, D. A. & Naghdi, P. M. 1977 The influence of twist on the motion of a straight elliptical jet. University of California, Berkeley, Dept Mech. Engng Rep. UCB/AM-77-5.
Caulk, D. A. & Naghdi, P. M. 1978 The onset of breakup in inviscid and viscous jets. University of California, Berkeley, Dept Mech. Engng Rep. UCB/AM-78-3.
Chandrasekhar, S. 1961 Hydrodynamic and Hydromagnetic Stability. Clarendon.
Chaudhary, K. C. 1977 Nonlinear capillary instability of a jet. PhD thesis, University of Southern California.
Chaudhary, K. C. & Maxworthy, T. 1980a The nonlinear capillary instability of a liquid jet. Part 2. Experiments on jet behavior before droplet formation. J. Fluid Mech. 96, 275–286.Google Scholar
Chaudhary, K. C. & Maxworthy, T. 1980b The nonlinear capillary instability of a liquid jet. Part 3. Experiments on satellite drop formation and control. J. Fluid Mech. 96, 287–297.Google Scholar
Chaudhary, K. C. & Redekopp, L. G. 1980 The nonlinear capillary instability of a liquid jet. Part 1. Theory. J. Fluid Mech. 96, 257–274.Google Scholar
Chin, R. H. 1983 Surface-tension-driven breakup of capillary jets of dilute polymer solutions. MS thesis, University of California, Berkeley.
Cline, H. E. & Anthony, T. R. 1978 The effects of harmonics on the capillary instability of liquid jets. J. Appl. Phys. 49, 3203–3208.Google Scholar
Crane, L., Birch, S. & McCormack, P. D. 1964 The effect of mechanical vibration on the breakup of a cylindrical water jet in air. Brit. J. Appl. Phys. 15, 743–750.Google Scholar
Donnelly, R. J. & Glaberson, W. 1966 Experiment on capillary instability of a liquid jet. Proc. R. Soc. Lond. A 290, 547–556.Google Scholar
Faidley, R. & Panton, R. L. 1990 Liquid jet instability induced by surface tension variations. Expl Thermal. Fluid Sci. 3, 383–387.Google Scholar
Fromm, J. E. 1984 Numerical calculation of the fluid dynamics of drop-on-demand. IBM J. Res. Dev. 28, 322–333.Google Scholar
Goedde, E. F. & Yuen, M. C. 1970 Experiments on liquid jet instability. J. Fluid Mech. 40, 495–511.Google Scholar
Green, A. E. 1976 On the non-linear behavior of fluid jets. Intl J. Engng Sci. 14, 49–63.Google Scholar
Green, A. E., Naghdi, P. M. & Wenner, M. L. 1974 On the theory of rods. II. Developments by direct approach. Proc. R. Soc. Lond. A 337, 485–507.Google Scholar
Hughes, T. J. R., Liu, W. K. & Brooks, A. 1979 Finite element analysis of incompressible viscous flows by penalty function formulation. J. Comput. Phys. 30, 1–60.Google Scholar
Kakutani, T., Inoue, Y. & Kan, T. 1974 Nonlinear capillary waves on the surface of liquid column. J. Phys. Soc. Japan 37, 529–538.Google Scholar
Keller, J. B., Rubinow, S. I. & Tu, Y. O. 1973 Spatial instability of a jet. Phys. Fluids 16, 2052–2055.Google Scholar
Keunings, R. 1986 An algorithm for the simulation of transient viscoelastic flows with free surfaces. J. Comput. Phys. 62, 199.Google Scholar
Kitamura, Y., Mishima, H. & Takahashi, T. 1982 Stability of jets in liquid-liquid systems. Can. J. Chem. Engng 60, 723–731.Google Scholar
Kitamura, Y. & Takahashi, T. 1982 Breakup of jets in power law non-Newtonian-Newtonian liquid systems. Can. J. Chem. Engng 60, 732–737.Google Scholar
Lafrance, P. 1975 Nonlinear break up of a laminar liquid jet. Phys. Fluids 18, 428–432.Google Scholar
Lee, H. C. 1974 Drop formation in a liquid jet. IBM J. Res. Dev. 18, 364–369.Google Scholar
Lieb, S. J. & Goldstein, M. L. 1986a The generation of capillary instabilities on liquid jet. J. Fluid Mech. 168, 479–500.Google Scholar
Lieb, S. J. & Goldstein, M. L. 1986b Convective and absolute instability of a viscous liquid jet. Phys. Fluids 29, 952–954.Google Scholar
Magnus, G. 1859 On the swellings formed in jets issuing from circular orifices. Phil. Mag. 18, 161–183.Google Scholar
Mansour, N. N. & Lundgren, T. S. 1990 Satellite formation in capillary jet breakup. Phys. Fluids A 2, 1141–1144.Google Scholar
Mashayek, F. & Ashgriz, N. 1993 A height flux method for simulating free surface flows and interfaces. Intl J. Numer. Meth. Fluids 17, 1035–1054.Google Scholar
McCarthy, M. J. & Molloy, N. A. 1974 Review of stability of liquid jets and the influence of nozzle design. Chem. Engng J. 7, 1–20.Google Scholar
Nayfeh, A. H. 1970 Nonlinear stability of a liquid jet. Phys. Fluids 13, 841–847.Google Scholar
Nayfeh, A. H. & Hassan, S. D. 1971 The method of multiple scales and nonlinear dispersive waves. J. Fluid Mech. 48, 463.Google Scholar
Ogg, J. C. & Schetz, J. A. 1984 Breakup and droplet formation of slurry jets. AIAA J. 23, 432–439.Google Scholar
Orme, M. & Muntz, E. P. 1990 The manipulation of capillary stream breakup using amplitude-modulated disturbances: A pictorial and quantitative representation. Phys. Fluids A 2, 1124–1140.Google Scholar
Orme, M., Willis, K. & Nguyen, T.-V. 1993 Droplet patterns from capillary stream breakup. Phys. Fluids A 5, 80–90.Google Scholar
Pimbley, W. T. 1976 Drop formation from a liquid jet: A linear one-dimensional analysis considered as a boundary value problem. IBM J. Res. Dev. 20, 148–156.Google Scholar
Pimbley, W. T. & Lee, H. C. 1977 Satellite droplet formation in a liquid jet. IBM J. Res. Dev. 21, 21–30.Google Scholar
Plateau, J. 1873 Statique experimentale et theorique des liquids soumis aux seules forces moleculaires. Cited by Lord Rayleigh, Theory of Sound, vol. II, p. 363, 1945. Dover.
Rayleigh, Lord 1879 On the instability of jets. Proc. Lond. Math. Soc. 10, 4–13.Google Scholar
Rayleigh, Lord 1882 Further observations upon liquid jets. Proc. Lond. Math. Soc. 34, 130–145.Google Scholar
Rayleigh, Lord 1896 Theory of Sound, vol. 2, 2nd edn. Macmillan. (Reprinted in 1945, Dover.)
Rutland, D. F. & Jameson, G. J. 1970 Theoretical prediction of the sizes of drops formed in the breakup of capillary jets. Chem. Engng Sci. 25 (11-E), 1689–1698.Google Scholar
Rutland, D. F. & Jameson, G. J. 1971 A non-linear effect in the capillary instability of liquid jets. J. Fluid Mech. 46, 267–271.Google Scholar
Savart, F. 1883 Memoire sur la constitution des veines liquides lancees par des orifices circulaires en mince paroi. Ann. Chimie Phys. 53, 337–386.Google Scholar
Schulkes, R. M. S. M. 1993 Dynamics of liquid jets revisited. J. Fluid Mech. 250, 635–650.Google Scholar
Shokoohi, F. & Elrod, H. G. 1987 Numerical investigation of the disintegration of liquid jets. J. Comput. Phys. 71, 324–342.Google Scholar
Smith, S. W. J. & Moss, H. 1917 Experiments with mercury jets. Proc. R. Soc. Lond. A 93, 373–393.Google Scholar
Taub, H. H. 1976 Investigation of non-linear waves on liquid jets. Phys. Fluids 19, 1124–1129.Google Scholar
Tjahjadi, M., Stone, H. A. & Ottino, J. M. 1992 Satellite and subsatellite formation in capillary breakup. J. Fluid Mech. 243, 297–317.Google Scholar
Torpey, P. A. 1989 A nonlinear theory for describing the propagation of disturbances on a capillary jet. Phys. Fluids A 1, 661–671.Google Scholar
Tyler, E. 1933 Instability of liquid jets. Phil. Mag. 16, 504–518.Google Scholar
Tyler, E. & Watkin, F. 1932 Experiments with capillary jets. Phil. Mag. 16, 849–881.Google Scholar
Vassallo, P. & Ashgriz, N. 1991 Satellite formation and merging in liquid jet breakup. Proc. R. Soc. Lond. A 433, 269–286.Google Scholar
Wang, D. P. 1968 Finite amplitude effect on the stability of a jet of circular cross-section. J. Fluid Mech. 34, 299–313.Google Scholar
Weber, C. 1931 Zum Zerfall eines Flussigkeitsstrahles. Z. Angew. Math. Mech. 11, 136–141.Google Scholar
Yuen, M. C. 1968 Non-linear capillary instability of a liquid jet. J. Fluid Mech. 33, 151–163.Google Scholar