Hostname: page-component-669899f699-vbsjw Total loading time: 0 Render date: 2025-04-25T12:38:09.034Z Has data issue: false hasContentIssue false
  • English
  • Français

Microlayer dynamics of hydrodynamically interacting vapour bubbles in flow boiling

Published online by Cambridge University Press:  10 March 2023

Sai Raja Gopal Vadlamudi Open the ORCID record for Sai Raja Gopal Vadlamudi [Opens in a new window] ,
Mohd Moiz Open the ORCID record for Mohd Moiz [Opens in a new window]  and
Atul Srivastava Open the ORCID record for Atul Srivastava [Opens in a new window]
Sai Raja Gopal Vadlamudi
Affiliation:
Department of Energy Science and Engineering, Indian Institute of Technology Bombay, Powai, 400076 Mumbai, India
Mohd Moiz
Affiliation:
Department of Mechanical Engineering, Indian Institute of Technology Bombay, Powai, 400076 Mumbai, India
Atul Srivastava*
Affiliation:
Department of Mechanical Engineering, Indian Institute of Technology Bombay, Powai, 400076 Mumbai, India
*
†Email address for correspondence: [email protected]
Get access Rights & Permissions [Opens in a new window]

Abstract

Nucleate boiling, a ubiquitous heat transfer mode, involves multiple vapour bubble nucleations on the heater surface and offers high heat transfer coefficients. The bubble growth process on a heating substrate involves the formation of microlayer, a thin liquid film trapped between the growing bubble and the heating substrate, and contributes to the bubble growth phenomenon through evaporation. Microlayer dynamics for a single bubble have been widely investigated in the pool and flow boiling conditions. However, the literature on multiple bubbles interactions and their associated microlayer information is scarce. Notably, in the case of flow boiling, where the microlayer dynamics are not symmetric due to the bubble's movement, the bubbles’ interaction and its influence on associated microlayer dynamics have never been reported. Therefore, microlayer and bubble dynamics in multiple interactions have been investigated experimentally using simultaneous application of thin-film interferometry and high-speed videography techniques in flow boiling with water as the working fluid. Our experimental investigation revealed that the secondary nucleation could cause a reduction in lift-off time and may assist or hinder the movement of the first bubble. The experimental results also demonstrated that the secondary nucleation could deplete the microlayer of the first bubble hydrodynamically even when the bubbles are far apart. Furthermore, it has been found that the microlayer depletion rate depends on the growth rate and the location of the secondary nucleation. Hence, this experimental study emphasises the need to consider the interaction of bubbles while modelling boiling flows to avoid overestimating the contribution of microlayer evaporation.

JFM classification

Drops and Bubbles: Boiling Drops and Bubbles: Bubble dynamics
Type
JFM Papers
Information
Journal of Fluid Mechanics , Volume 958 , 10 March 2023 , A44
Check for updates
Copyright
© The Author(s), 2023. Published by Cambridge University Press

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

Article purchase

Temporarily unavailable

References

Baglietto, E., Demarly, E. & Kommajosyula, R. 2019 Boiling crisis as the stability limit to wall heat partitioning. Appl. Phys. Lett. 114 (10), 103701.CrossRefGoogle Scholar
Bonjour, J., Clausse, M. & Lallemand, M. 2000 Experimental study of the coalescence phenomenon during nucleate pool boiling. Exp. Therm. Fluid Sci. 20 (3–4), 180–187.CrossRefGoogle Scholar
Bucci, M., Buongiorno, J. & Bucci, M. 2021 The not-so-subtle flaws of the force balance approach to predict the departure of bubbles in boiling heat transfer. Phys. Fluids 33 (1), 017110.CrossRefGoogle Scholar
Chen, Z., Hu, X., Hu, K., Utaka, Y. & Mori, S. 2020 Measurement of the microlayer characteristics in the whole range of nucleate boiling for water by laser interferometry. Intl J. Heat Mass Transfer 146, 118856.CrossRefGoogle Scholar
Choi, M., Chu, I.C., Kim, S., Jeon, B.G. & Jo, H.J. 2020 Direct observation of rewetting failure mechanism at CHF under different subcooled flows. Intl J. Heat Mass Transfer 163, 120465.CrossRefGoogle Scholar
Colombo, M. & Fairweather, M. 2016 Accuracy of Eulerian–Eulerian, two-fluid CFD boiling models of subcooled boiling flows. Intl J. Heat Mass Transfer 103, 28–44.CrossRefGoogle Scholar
Cooper, M.G. & Lloyd, A.J.P. 1969 The microlayer in nucleate pool boiling. Intl J. Heat Mass Transfer 12, 895–913.CrossRefGoogle Scholar
Del Valle, V.H. & Kenning, D.B.R. 1985 Subcooled flow boiling at high heat flux. Intl J. Heat Mass Transfer 28 (10), 1907–1920.CrossRefGoogle Scholar
Gao, M., Zhang, L., Cheng, P. & Quan, X. 2012 An investigation of microlayer beneath nucleation bubble by laser interferometric method. Intl J. Heat Mass Transfer 57 (1), 183–189.CrossRefGoogle Scholar
Giustini, G., Jung, S., Kim, H., Ardron, K.H. & Walker, S.P. 2019 Microlayer evapouration during steam bubble growth. Intl J. Therm. Sci. 137, 45–54.CrossRefGoogle Scholar
Golobic, I., Petkovsek, J. & Kenning, D.B.R. 2012 Bubble growth and horizontal coalescence in saturated pool boiling on a titanium foil, investigated by high-speed IR thermography. Intl J. Heat Mass Transfer 55 (4), 1385–1402.CrossRefGoogle Scholar
von Hardenberg, J., Kenning, D.B.R., Xing, H. & Smith, L.A. 2004 Identification of nucleation site interactions. Intl J. Heat Fluid Flow 25 (2), 298–304.CrossRefGoogle Scholar
Jawurek, H.H. 1969 Simultaneous determination of microlayer geometry and bubble growth in nucleate boiling. Intl J. Heat Mass Transfer 12 (8), 843–848.CrossRefGoogle Scholar
Jones, R.C. & Judd, R.L. 2003 An investigation of dryout/rewetting in subcooled two-phase flow boiling. Intl J. Heat Mass Transfer 46 (17), 3143–3152.CrossRefGoogle Scholar
Judd, R.L. & Chopra, A. 1993 Interaction of the nucleation processes occurring at adjacent nucleation sites. Trans. ASME J. Heat Transfer 115 (4), 955–962.CrossRefGoogle Scholar
Jung, S. & Kim, H. 2014 An experimental method to simultaneously measure the dynamics and heat transfer associated with a single bubble during nucleate boiling on a horizontal surface. Intl J. Heat Mass Transfer 73, 365–375.CrossRefGoogle Scholar
Jung, S. & Kim, H. 2015 An experimental study on heat transfer mechanisms in the microlayer using integrated total reflection, laser interferometry and infrared thermometry technique. Heat Transfer Engng 36 (12), 1002–1012.CrossRefGoogle Scholar
Jung, S. & Kim, H. 2019 Observation of the mechanism triggering critical heat flux in pool boiling of saturated water under atmospheric pressure. Intl J. Heat Mass Transfer 128, 229–238.CrossRefGoogle Scholar
Kangude, P. & Srivastava, A. 2022 On the coupled thermal and hydrodynamic interaction of adjacently located vapour bubbles on highly wetting surfaces. Langmuir 38 (45), 13647–13658.CrossRefGoogle ScholarPubMed
Koffman, L.D. 1983 Analysis of microlayer evapouration in subcooled nucleate boiling. In 3rd Multi-Phase Flow and Heat Transfer Symposium.Google Scholar
Moore, F.D. & Mesler, R.B. 1961 The measurement of rapid surface temperature fluctuations during nucleate boiling of water. AIChE J. 7 (4), 620–624.CrossRefGoogle Scholar
Mukherjee, A. & Dhir, V.K. 2004 Study of lateral merger of vapour bubbles during nucleate pool boiling. J. Heat Transfer 126 (6), 1023–1039.CrossRefGoogle Scholar
Otsu, N. 1979 A threshold selection method from gray-level histograms. IEEE Trans. Syst. Man Cybern. 9 (1), 62–66.CrossRefGoogle Scholar
Richenderfer, A., Kossolapov, A., Seong, J.H. & Bucci, M. 2018 Investigation of subcooled flow boiling and CHF using high-resolution diagnostics. Exp. Therm. Fluid Sci. 99, 35–58.CrossRefGoogle Scholar
Sato, Y. & Niceno, B. 2015 A depletable micro-layer model for nucleate pool boiling. J. Comput. Phys. 300, 20–52.CrossRefGoogle Scholar
Sharp, R.R. 1964 The Nature of Liquid Film Evapouration during Nucleate Boiling. National Aeronautics and Space Administration.Google Scholar
Sinha, G.K., Narayan, S. & Srivastava, A. 2022 Microlayer dynamics during the growth process of a single vapour bubble under subcooled flow boiling conditions. J. Fluid Mech. 931, 23.CrossRefGoogle Scholar
Suryanarayan, L. & Srivastava, A. 2021 On the identification and mapping of three distinct stages of single vapour bubble growth with the corresponding microlayer dynamics. Intl J. Multiphase Flow 142, 103722.Google Scholar
Utaka, Y., Hu, K., Chen, Z. & Morokuma, T. 2018 Measurement of contribution of microlayer evapouration applying the microlayer volume change during nucleate pool boiling for water and ethanol. Intl J. Heat Mass Transfer 125, 243–247.CrossRefGoogle Scholar
Vadlamudi, S.R.G., Sinha, G.K., Srivastava, A. & Singh, S. 2022 Dynamic interaction of growing bubble and microlayer: need for reconciliation of experiments and theory in flow boiling. Appl. Phys. Lett. 121 (12), 124101.CrossRefGoogle Scholar
Yoo, J., Estrada Perez, C.E. & Hassan, Y.A. 2021 Force balance model predictions of sliding bubbles velocity in vertical subcooled boiling flow. Intl J. Heat Mass Transfer 175, 121368.CrossRefGoogle Scholar
Zhang, L. & Shoji, M. 2003 Nucleation site interaction in pool boiling on the artificial surface. Intl J. Heat Mass Transfer 46 (3), 513–522.CrossRefGoogle Scholar