Hostname: page-component-586b7cd67f-dsjbd Total loading time: 0 Render date: 2024-11-26T14:03:24.271Z Has data issue: false hasContentIssue false
  • English
  • Français

An experimental study of low-Reynolds-number exchange flow of two Newtonian fluids in a vertical pipe

Published online by Cambridge University Press:  28 July 2011

F. M. BECKETT ,
H. M. MADER ,
J. C. PHILLIPS ,
A. C. RUST  and
F. WITHAM
F. M. BECKETT*
Affiliation:
Department of Earth Sciences, Wills Memorial Building, Bristol BS8 1RJ, UK
H. M. MADER
Affiliation:
Department of Earth Sciences, Wills Memorial Building, Bristol BS8 1RJ, UK
J. C. PHILLIPS
Affiliation:
Department of Earth Sciences, Wills Memorial Building, Bristol BS8 1RJ, UK
A. C. RUST
Affiliation:
Department of Earth Sciences, Wills Memorial Building, Bristol BS8 1RJ, UK
F. WITHAM
Affiliation:
Department of Earth Sciences, Wills Memorial Building, Bristol BS8 1RJ, UK
*
†Email address for correspondence: [email protected]
Get access Rights & Permissions [Opens in a new window]

Abstract

We present an experimental study of a buoyancy-driven, low-Reynolds-number (Re < 1) exchange flow of two Newtonian fluids in a vertical cylindrical pipe (length 1 m and diameter 38.4 mm) connecting two fluid reservoirs. The denser, more viscous fluid was golden syrup and the less dense, less viscous fluid was a golden syrup–water solution; the ratio of the viscosities of the two fluids (β) ranged from 2 to 1180. Flows were initiated by removing a bung in the base of the upper reservoir or sliding out a gate positioned at the top, middle or bottom of the pipe. We observe the flows over long time durations (up to 356 h), and define the development of the flow with reference to a non-dimensional time (τ). The initial transient development of the flow was dependent on which of the two fluids initially filled the pipe, but this did not systematically affect the flow regime observed at τ ≫ 1. Two distinct flow regimes were observed: axisymmetric core-annular flow (CAF), in which the less viscous fluid occupies a cylindrical core and the denser fluid flows downwards in an annulus, and side-by-side (SBS) flow where both fluids are in contact with the pipe and there is a single interface between them. CAF formed at β ≥ 75 and SBS flow at β ≤ 117. In several experiments, for 5 ≤ β ≤ 59, a slowly developing transitional SBS (TSBS) flow was observed where SBS flow and CAF occurred simultaneously with SBS in the lower portion of the pipe; SBS existed throughout most of the pipe and in one case grew with time to entirely fill the pipe. Velocity profiles determined by tracking tracer particles show that the observed CAFs are adequately described by the formulation of Huppert & Hallworth (J. Fluid Mech., vol. 578, 2007, pp. 95–112). Experimental SBS velocity profiles are not well produced by the formulation of Kerswell (J. Fluid Mech., 10.1017/jfm.2011.190), possibly because the latter is restricted to flows whose cross-section has an interface of constant curvature. Despite the variations in flow regime, volume fluxes can be described by a power-law function of β, Q1 = 0.059 β−0.74. A comparison of experimental data with the theoretical approaches of Huppert Hallworth (2007) and Kerswell (2011) indicates that fluids are not arranged in the regime that maximises volume flux (e.g. SBS or CAF), nor do they adopt the geometry that maximises volume flux within that particular regime.

JFM classification

Multiphase and Particle-laden Flows: Core-annular flow Geophysical and Geological Flows: Magma and lava flow
Type
Papers
Information
Journal of Fluid Mechanics , Volume 682 , 10 September 2011 , pp. 652 - 670
Copyright
Copyright © Cambridge University Press 2011

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

Arakeri, J. H., Avila, F. E., Dada, J. M. & Tovar, R. O. 2000 Convection in long vertical tube due to unstable stratification: A new type of turbulent flow? Current Science 79, 859–866.Google Scholar
Burton, M. R., Mader, H. M. & Polacci, M. 2007 The role of gas percolation in quiescent degassing of persistently active basaltic volcanoes. Earth Planet. Sci. Lett. 264, 46–60.Google Scholar
Cholemari, M. R. & Arakeri, J. H. 2005 Experiments and a model of turbulent exchange flow in a vertical pipe. Intl J. Heat Mass Transfer 48, 4467–4473.Google Scholar
Dalziel, S. B. 1992 Maximal exchange in channels with nonrectangular cross sections. J. Phys. Oceanogr. 22, 1188–1206.Google Scholar
Debacq, M., Fanguet, V., Hulin, J. P., Salin, D. & Perrin, B. 2001 Self-similar concentration profiles in buoyant mixing of miscible fluids in a vertical tube. Phys. Fluids 13, 3097–3100.Google Scholar
Debacq, M., Hulin, J. P., Salin, D., Perrin, B. & Hinch, E. J. 2003 Buoyant mixing of miscible fluids of varying viscosities in vertical tubes. Phys. Fluids 15, 3846–3855.Google Scholar
d'Olce, M., Martin, J., Rakotomalala, N., Salin, D. & Talon, L. 2008 Pearl and mushroom instability patterns in two miscible fluids' core annular flows. Phys. Fluids 20, 024104.CrossRefGoogle Scholar
d'Olce, M., Martin, J., Rakotomalala, N., Salin, D. & Talon, L. 2009 Convective/absolute instability in miscible core-annular flow. Part 1. Experiments. J. Fluid. Mech 618, 305–322.CrossRefGoogle Scholar
Everage, A. E. 1973 Theory of stratified bicomponent flow of polymer melts. 1. Equilibrium Newtonian tube flow. Trans. Soc. Rheol. 17, 629–646.Google Scholar
Frigaard, I. A. & Scherzer, O. 1998 Uniaxial exchange flows of two Bingham fluids in a cylindrical duct. IMA J. Appl. Maths 61, 237–266.CrossRefGoogle Scholar
Huppert, H. E. & Hallworth, M. A. 2007 Bi-directional flows in constrained systems. J. Fluid Mech. 578, 95–112.Google Scholar
Jaluria, Y., Lee, S. H. K., Mercier, G. P. & Tan, Q. 1998 Transport processes across a horizontal vent due to density and pressure differences. Exp. Therm. Fluid Sci. 16, 260–273.Google Scholar
Joseph, D. D., Nguyen, K. & Beavers, G. S. 1984 Non-uniqueness and stability of the configuration of flow of immiscible fluids with different viscosities. J. Fluid Mech. 141, 319–345.CrossRefGoogle Scholar
Kazahaya, K., Shinohara, H. & Saito, G. 1994 Excessive degassing of Izu-Oshima volcano: magma convection in a conduit. Bull. Volcanol. 56, 207–216.Google Scholar
Kerswell, R. R. 2011 Exchange flow of two immiscible fluids and the principle of maximum flux. J. Fluid. Mech. 10.1017/jfm.2011.190.Google Scholar
Lee, B. L. & White, J. L. 1974 An experimental study of rheological properties of polymer melts in laminar shear flow and of interface deformation and its mechanisms in two phase stratified flow. Trans. Soc. Rheol. 18, 467–492.Google Scholar
Minagawa, N. & White, J. L. 1975 Co-extrusion of unfilled and TiO2-filled polyethylene: Influence of viscosity and die cross-section on interface shape. Poly. Engng Sci. 15, 825–830.Google Scholar
Séon, T., Hulin, J. P., Salin, D., Perrin, B. & Hinch, E. J. 2005 Buoyancy driven miscible front dynamics in tilted tubes. Phys. Fluids 17, 031702.Google Scholar
Southern, J. H. & Ballman, R. I. 1975 Additional observations on stratified bicomponent flow of polymer melts in a tube. J. Poly. Sci 13, 863–869.Google Scholar
Stevenson, D. S. & Blake, S. 1998 Modelling the dynamics and thermodynamics of volcanic degassing. Bull. Volcanol. 60, 307–317.Google Scholar
Williams, M. C. 1975 Migration of two liquid phases in capillary extrusion: An energy interpretation. AIChE J. 21, 1204–1207.CrossRefGoogle Scholar
Witham, F. 2011 Conduit convection, magma mixing, and melt inclusion trends at persistently degassing volcanoes. Earth Planet. Sci. Lett. 301, 345–352.Google Scholar
Znaien, J., Hallez, Y., Moisy, F., Magnaudet, J., Hulin, J. P., Salin, D. & Hinch, E. J. 2009 Experimental and numerical investigations of flow structure and momentum transport in a turbulent buoyancy-driven flow inside a tilted tube. Phys. Fluids 21, 115102.CrossRefGoogle Scholar