Hostname: page-component-78c5997874-v9fdk Total loading time: 0 Render date: 2024-11-04T21:02:38.147Z Has data issue: false hasContentIssue false
  • English
  • Français

Computational investigation of combustion instabilities in an air heater with a new computational model

Published online by Cambridge University Press:  30 April 2021

L. Yuan Open the ORCID record for L. Yuan [Opens in a new window]  and
C. Shen
L. Yuan*
Affiliation:
China Aerodynamics Research and Development Center, Mianyang, Sichuan621000, China
C. Shen*
Affiliation:
Science and Technology on Scramjet Laboratory, College of Aerospace Science and Engineering, National University of Defense Technology, Changsha, 410073, China
*
[email protected]
[email protected]
Get access Rights & Permissions [Opens in a new window]

Abstract

On the basis of air heater characteristics, a new computational model was developed in this paper, which was aimed at investigating acoustics and instabilities in air heaters. This model included the effects of mean flow, viscosity, entropy waves, non-linear acoustics and realistic boundary conditions. In addition, it was practical for air heaters with hundreds of injectors, complex configurations and geometries. Analytical solutions of acoustics in a closed rectangular cavity were used to verify and validate the computational model. It was shown that the predicted critical parameters of air heater agreed well with the experimental data or design values. This model predicted the self-excited spinning tangential modes without any preliminary assumptions about them. Traditional combustion response function assumes that combustion mainly takes place in a so-called rapid combustion zone, and this zone is usually modelled as a disc in the combustor near the injection head. However, in practice, the flame has a spatial distribution. This paper described the effect of flame spatial distribution on predictions of oscillation frequency and mode. It was found that frequency and mode shape of oscillations closely depended on the length of the heat release zone. Comparison of different heat release zones indicated that the increment of heat release length exhibited an increased tendency toward lower-order longitudinal modes, when the heat release zone was located near the faceplate where it was the pressure antinode of the longitudinal mode. Modulation of heat release length might cause bifurcations between standing and turning modes. A noticeable tendency was toward higher-order standing tangential mode with increasing heat release length. Finally, theoretical analysis of the modal behaviour, i.e. standing or spinning waves, was performed.

Keywords

air heaterliquid rocket enginehigh-frequency combustion instabilitynumerical computationheat release distribution
Type
Research Article
Information
The Aeronautical Journal , Volume 125 , Issue 1290 , August 2021 , pp. 1408 - 1433
Copyright
© The Author(s), 2021. Published by Cambridge University Press on behalf of Royal Aeronautical Society

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

Fetterhoff, T., Kraft, E. and Laster, M.L. High-speed/hypersonic test and evaluation infrastructure capabilities study. 14th AIAA/AHI Space Planes and Hypersonic Systems and Technologies Conference, Canberra, Australia, 6–9 November 2006, AIAA 2006-8043.10.2514/6.2006-8043CrossRefGoogle Scholar
Leslie, J.D. and Marren, D.E. Hypersonic test capabilities overview. U.S. Air Force T&E Days, Albuquerque, New Mexico, 10–12 February 2009, AIAA 2009-1702.10.2514/6.2009-1702CrossRefGoogle Scholar
Pellett, G.L., Bruno, C. and Chinitz, W. Review of air vitiation effects on scramjet ignition and flameholding combustion processes. 38th AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit, Indianapolis, Indiana, 7–10 July 2002, AIAA 2002-3880.CrossRefGoogle Scholar
Saari, D.P., Jauch, C.E. and Chu, P.H. Clean air regenerative storage heater technology for propulsion test facilities ”16th AIAA/DLR/DGLR International Space Planes and Hypersonic Systems and Technologies Conference, Bremen, Germany, 19–22 October 2009, AIAA 2009-7377.CrossRefGoogle Scholar
Harrje, D.T. and Readon, F.H. Liquid propellant rocket combustion instability, NASA, 1972, Washington, DC.Google Scholar
Yang, V. and Anderson, W.E. Liquid rocket engine combustion instability, AIAA, 1995, Washington, DC.Google Scholar
Culick, F.E.C. Unsteady motions in combustion chambers for propulsion systems, AGARD & RTO, 2006, Virginia.Google Scholar
Pieringer, J., Sattelmayer, T. and Fassl, F. Simulation of combustion instabilities in liquid rocket engines with acoustic perturbation equations. J Propuls Power, 2009, 25, (5), pp 1020–1031. doi: 10.2514/1.38782 CrossRefGoogle Scholar
Zinn, B.T. A theoretical study of nonlinear combustion instability in liquid propellant engines. AIAA J, 1968, 6, (10), pp 1966–1972. doi: 10.2514/3.4908 CrossRefGoogle Scholar
Culick, F.E.C. Combustion instabilities in propulsion systems, combustion instabilities in liquid-fuelled propulsion systems. Propulsion and Energetics Panel 72 nd B Specialists’ Meeting (Bath,UK), AGARD, Neuilly-sur-Seine, France, 6–7 October 1988, NATO.Google Scholar
Portillo, J.E., Sisco, J.C., Yu, Y. and Anderson, W.E. Application of a generalized instability model to a longitudinal mode combustion instability ”43rd AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit, Cincinnati, OH, 8–11 July 2007, AIAA 2007-5651.10.2514/6.2007-5651CrossRefGoogle Scholar
Portillo, J.E., Sisco, J.C., Corless, M.J., Sankaran, V. and Anderson, W.E. Generalized combustion instability model ”42nd AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit, Sacramento, CA, 9–12 July 2006, AIAA 2006-4889.CrossRefGoogle Scholar
Yu, Y.C., Sisco, J. and Anderson, W.E. Examination of spatial mode shapes and resonant frequencies using linearized Euler solutions. 37th AIAA Fluid Dynamics Conference and Exhibit, Miami, FL, 25–28 June 2007, AIAA 2007-3999.10.2514/6.2007-3999CrossRefGoogle Scholar
Sisco, J.C., Yu, Y.C., Sankaran, V. and Anderson, W.E. Examination of mode shapes in an unstable model combustor. J Sound Vib, 2011, (330), pp 61–74. doi: 10.1016/j.jsv.2010.07.016 CrossRefGoogle Scholar
Quinlan, J.M., Kirkpatrick, A.T., Milano, D. and Mitchell, C.E. Analytical and numerical development of a baffled liquid rocket combustion stability code ”45th AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit, Denver, CO, 2–5 August 2009, AIAA 2009-4865.CrossRefGoogle Scholar
Frezzotti, M.L., Terracciano, A., Nasuti, F., Hester, S. and Anderson, W.E. Low-order model studies of combustion instabilities in a DVRC combustor. 50th AIAA/ASME/SAE/ASEE Joint Propulsion Conference, Cleveland, OH, July 28–30, 2014, AIAA 2014-3485.CrossRefGoogle Scholar
Harvazinski, M.E., Talley, D.G. and Sankaran, V. Comparison of a structured-LES and an unstructured-DES code for predicting combustion instabilities in a longitudinal mode rocket combustor. 53rd AIAA Aerospace Sciences Meeting, Kissimmee, Florida, 5–9 January 2015, AIAA 2015-1608.10.2514/6.2015-1608CrossRefGoogle Scholar
Gaby, R., Selle, L. and Poinsot, T. Large-eddy simulation of combustion instabilities in a variable-length combustor. Comptes Rendus MÉcanique, 2013, 341, (1–2), pp 220–229. doi: 10.1016/j.crme.2012.10.020 Google Scholar
Matsuyama, S., Shinjo, J., Ogawa, S. and Mizobuchi, Y. Large eddy simulation of high-frequency combustion instability of supercritical LOX /GH2 flame ”46th AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit, Nashville, TN, 25–28 July 2010, AIAA 2010-6567.CrossRefGoogle Scholar
Matsuyama, S., Shinjo, J., Ogawa, S. and Mizobuchi, Y. LES of high-frequency combustion instability in a single element rocket combustor. 50th AIAA Aerospace Sciences Meeting including the New Horizons Forum and Aerospace Exposition, Nashville, TN, 9–12 January 2012, AIAA 2012-1271.10.2514/6.2012-1271CrossRefGoogle Scholar
Matsuyama, S., Shinjo, J. and Mizobuchi, Y. LES of high-frequency combustion instability in a rocket combustor. 51st AIAA Aerospace Sciences Meeting including the New Horizons Forum and Aerospace Exposition, Grapevine (Dallas/Ft. Worth Region), TX, 7–10 January 2013, AIAA 2013-0564.CrossRefGoogle Scholar
Yuan, L. and Shen, C.B. Large eddy simulation of combustion instability in a tripropellant air heater. Acta Astronaut, 2016, 129, pp 59–73. doi: 10.1016/j.actaastro.2016.08.002 CrossRefGoogle Scholar
Sattelmayer, T., Kathan, R. and KÖglmeier, S. Validation of transverse instability damping computations for rocket engines. J Propuls Power, 2015, 31, (4), pp 1148–1158. doi: 10.2514/1.B35536 CrossRefGoogle Scholar
Shimizu, T., Morii, Y. and Hori, D. Numerical study on intense tangential oscillation in a simulated liquid rocket chamber. AIAA J, 52, (8, 2014, pp 1795-1799. doi: 10.2514/1.J052627 CrossRefGoogle Scholar
Shimizu, T., Tachibana, S., Yoshida, S., Hori, D., Matsuyama, S. and Mizobuchi, Y. Intense tangential pressure oscillations inside a cylindrical chamber. AIAA J, 2011, 49, (10), pp 2272–2281. doi: 10.2514/1.J051047 CrossRefGoogle Scholar
Qin, J.X., Zhang, H.Q. and Wang, B. Numerical evaluation of acoustic characteristics and their damping of a thrust chamber using a constant-volume bomb model. Chinese J Aeronaut, 2018, 31, (3), pp 470–480. doi: 10.1016/j.cja.2018.01.007 CrossRefGoogle Scholar
Kato, S., Fujimori, T., Dowling, A.P. and Kobayashi, H. Effect of heat release distribution on combustion oscillation. Proceedings of the Combustion Institute, 2005, 30, pp 1799–1806. doi: 10.1016/j.proci.2004.08.154 CrossRefGoogle Scholar
Smith, R., Xia, G., Anderson, W.E. and Merkle, C.L. Computational modeling of instabilities in a single-element rocket combustor using a response function. 43rd AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit, Cincinnati, OH, 8–11 July 2007, AIAA 2007-5564.CrossRefGoogle Scholar
Smith, R., Ellis, E., Xia, G., Sankaran, V., Anderson, W.E. and Merkle, C.L. Computational investigation of acoustics and instabilities in a longitudinal-mode rocket combustor. AIAA J, 2008, 46, (11), pp 2659–2673. doi: 10.2514/1.28125 CrossRefGoogle Scholar
Hantschk, C.C. and Vortmeyer, D. Numerical simulation of self-excited thermoacoustic instabilities in a rijke tube. J Sound Vib, 1999, 277, (3), pp 511–522.10.1006/jsvi.1999.2296CrossRefGoogle Scholar
Poinsot, T. and Veynante, D., Theoretical and Numerical Combustion , Ewards, 2005, Philadelphia.Google Scholar
Zhao, D., Li, S.H., Yang, W.M. and Zhang, Z.G. Numerical investigation of the effect of distributed heat sources on heat-to-sound conversion in a T-shaped thermoacoustic system. Appl Energy, 2015, 144, pp 204–213. doi: 10.1016/j.apenergy.2015.01.091 CrossRefGoogle Scholar
Smith, R. Computational investigations of high frequency acoustics and instabilities in a single-element rocket combustor, West Lafayette, IN, 2010, Purdue University, p 230.Google Scholar
Esteban, D., Gonzalez, J. and Aleksanda, J. Finite volume time-domain solver to estimate combustion instabilities. J Propuls Power, 2015, 31, (2), pp 632–642. doi: 10.2514/1.B35488 Google Scholar
Richecoeur, F., ExpÉrimentations et simulations numÉriques des intÉractions entre modes acoustiques transverses et flammes cryotechniques, Ecole Centrale Paris, 2006, CNRS, p 240.Google Scholar
Schuermans, B., Paschereit, C. and Monkiewitz, P. Non-linear combustion instabilities in annular gas-turbine combustors. 44th AIAA Aerospace Sciences Meeting and Exhibit, Reno, NV, 9–12 January 2006, AIAA 2006-0549.CrossRefGoogle Scholar
Schuermans, B., Bellucci, V. and Paschereit, C. Thermoacoustic modeling and control of multiburner combustion systems. International Gas Turbine and Aeroengine Congress & Exposition, Atlanta, GA, 2003, ASME Paper.10.1115/GT2003-38688CrossRefGoogle Scholar
Wolf, P., Staffelbach, G., Gicquel, L.Y.M., MÜller, J.-D. and Poinsot, T. Acoustic and large eddy simulation studies of azimuthal modes in annular combustion chambers. Combust Flame, 2012, 159, pp 3398–3413. doi: 10.1016/j.combustflame.2012.06.016 CrossRefGoogle Scholar
Evesque, S., Polifke, C. and Pankiewitz, C. Spinning and azimuthally standing acoustic modes in annular combustors. 9th AIAA/CEAS Aeroacoustics Conference, South Carolina, 2003, AIAA 2003-3182.CrossRefGoogle Scholar
Noiray, N., Bothien, M. and Schuermans, B. Investigation of azimuthal staging concepts in annular gas turbines. Combust Theor Model, 2011, 15, (4), pp 585–606. doi: 10.1080/13647830.2011.552636 CrossRefGoogle Scholar
Supplementary material: File

Yuan and Shen supplementary material

Appendix A

Download Yuan and Shen supplementary material(File)
File 80.8 KB