Hostname: page-component-586b7cd67f-t7fkt Total loading time: 0 Render date: 2024-11-23T11:20:18.521Z Has data issue: false hasContentIssue false
  • English
  • Français

Synthesis of Water-soluble Silicon Oxide Material by Sol-gel Reaction in Tetraalkoxysilane-aminoalkyltrialkoxysilane Binary System

Published online by Cambridge University Press:  01 August 2005

Yoshiro Kaneko ,
Nobuo Iyi ,
Taki Matsumoto  and
Hisanao Usami
Yoshiro Kaneko*
Affiliation:
Department of Nano-structured & Advanced Materials, Graduate School of Science and Engineering, Kagoshima University, Kagoshima 890-0065, Japan
Nobuo Iyi
Affiliation:
Advanced Materials Laboratory, National Institute for Materials Science (NIMS), Tsukuba, Ibaraki 305-0044, Japan
Taki Matsumoto
Affiliation:
Department of Fine Materials Engineering, Faculty of Textile Science and Technology, Shinshu University, Ueda 386-8567, Japan
Hisanao Usami
Affiliation:
Department of Fine Materials Engineering, Faculty of Textile Science and Technology, Shinshu University, Ueda 386-8567, Japan
*
a) Address all correspondence to this author. e-mail: [email protected]
Get access

Abstract

A series of water-soluble silicon oxide materials was synthesized by the sol-gel reaction of tetramethoxysilane (TMOS)/3-aminopropyltrimethoxysilane (APTMOS) mixtures catalyzed by hydrochloric acid with varying TMOS/APTMOS ratios. Increase in TMOS composition made the products less water-soluble, and the richest TMOS composition for the water-soluble silicon oxide materials was found to be TMOS/APTMOS = 7/3 (mol/mol). Ultraviolet-visible spectroscopy of a 10 wt% aqueous solution of the product with TMOS/APTMOS = 7/3 showed a high transmittance in the visible region. Its infrared spectrum showed an absorptionband attributable to the Si–O bond, and the 29Si dipole decoupled/magic angle spinning–nuclear magnetic resonance spectrum exhibited signals in the regions of T3, Q3, and Q4, indicating a dense siloxane network structure. A peak due to an ordered structure with a 1.76 nm periodicity was observed in the x-ray diffraction profile, and a stripe pattern was observed in the transmission electron microscopy image. These results indicate that the rodlike silicon oxide macromolecules with a 1–2-nm diameter stack parallel. Thus a silicon oxide material with nano-ordered structure was successfully formed and such a structure produced the water solubility.

Keywords

CompositeNanoscaleSol-gel
Type
Articles
Information
Journal of Materials Research , Volume 20 , Issue 8 , August 2005 , pp. 2199 - 2204
Copyright
Copyright © Materials Research Society 2005

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1Pinnavaia, T.J. and Beall, G.W.: Polymer-Clay Nanocomposites (John Wiley & Sons, Chichester, U.K., 2000).Google Scholar
2Usuki, A., Kojima, Y., Kawasumi, M., Okada, A., Fukushima, Y., Kurauchi, T. and Kamigaito, O.: Synthesis of nylon 6-clay hybrid. J. Mater. Res. 8, 1179 (1993).CrossRefGoogle Scholar
3Lan, T. and Pinnavaia, T.J.: Clay-reinforced epoxy nanocomposites. Chem. Mater. 6, 2216 (1994).CrossRefGoogle Scholar
4Sun, T. and Garcés, J.M.: High-performance polypropylene-clay nanocomposites by in-situ polymerization with metallocene/clay catalysts. Adv. Mater. 14, 128 (2002).3.0.CO;2-7>CrossRefGoogle Scholar
5Viville, P., Lazzaroni, R., Pollet, E., Alexandre, M. and Dubois, P.: Controlled polymer grafting on single clay nanoplatelets. J. Am. Chem. Soc. 126, 9007 (2004).CrossRefGoogle ScholarPubMed
6Ogawa, M. and Kuroda, K.: Photofunctions of intercalation compounds. Chem. Rev. 95, 399 (1995).CrossRefGoogle Scholar
7Ogawa, M. and Kuroda, K.: Preparation of inorganic-organic nanocomposites through intercalation of organoammonium ions into layered silicates. Bull. Chem. Soc. Jpn. 70, 2593 (1997).CrossRefGoogle Scholar
8Feng, X., Fryxell, G.E., Wang, L-Q., Kim, A.Y., Liu, J. and Kemner, K.M.: Functionalized monolayers on ordered mesoporous supports. Science 276, 923 (1997).CrossRefGoogle Scholar
9Kimura, T., Saeki, S., Sugahara, Y. and Kuroda, K.: Organic modification of FSM-type mesoporous silicas derived from kanemite by silylation. Langmuir 15, 2794 (1999).CrossRefGoogle Scholar
10Stein, A., Melde, B.J. and Schroden, R.C.: Hybrid inorganic-organic mesoporous silicates—Nanoscopic reactors coming of age. Adv. Mater. 12, 1403 (2000).3.0.CO;2-X>CrossRefGoogle Scholar
11Lim, J.E., Shim, C.B., Kim, J.M., Lee, B.Y. and Yie, J.E.: Dehydroxylation route to surface modification of mesoporous silicas by using Grignard reagents. Angew. Chem. Int. Ed. Engl. 43, 3839 (2004).CrossRefGoogle ScholarPubMed
12Olmos, D., Aznar, A.J., Baselga, J. and Gonzalez-Benito, J.: Kinetic study of epoxy curing in the glass fiber/epoxy interface using dansyl fluorescence. J. Colloid Interface Sci. 267, 117 (2003).CrossRefGoogle ScholarPubMed
13The, D.T., Yoshii, F., Nagasawa, N. and Kume, T.: Synthesis of poly(butylene succinate)/glass fiber composite by irradiation and its biodegradability. J. Appl. Polym. Sci. 91, 2122 (2004).CrossRefGoogle Scholar
14Leal, O., Bolívar, C., Ovalles, C., García, J.J. and Espidel, Y.: Reversible adsorption of carbon dioxide on amine surface-bonded silica gel. Inorg. Chim. Acta 240, 183 (1995).CrossRefGoogle Scholar
15Kaneko, Y., Iyi, N., Kurashima, K., Matsumoto, T., Fujita, T. and Kitamura, K.: Hexagonal-structured polysiloxane material prepared by sol-gel reaction of aminoalkyltrialkoxysilane without using surfactants. Chem. Mater. 16, 3417 (2004).CrossRefGoogle Scholar
16Kaneko, Y., Iyi, N., Matsumoto, T. and Kitamura, K.: Synthesis of rodlike polysiloxane with hexagonal phase by sol–gel reaction of organotrialkoxysilane monomer containing two amino groups. Polymer 46, 1828 (2005).CrossRefGoogle Scholar
17Kaneko, Y., Iyi, N., Matsumoto, T. and Kitamura, K.: Preparation of higher-ordered inorganic-organic nanocomposite composed of rodlike cationic polysiloxane and polyacrylate. J. Mater. Chem. 15, 1572 (2005).CrossRefGoogle Scholar
18Shimojima, A., Umeda, N. and Kuroda, K.: Synthesis of layered inorganic-organic nanocomposite films from mono-, di-, and trimethoxy(alkyl)silane-tetramethoxysilane systems. Chem. Mater. 13, 3610 (2001).CrossRefGoogle Scholar
19Ujiie, S. and Iimura, K.: Formation of smectic orientational order in an ionic thermotropic liquid-crystalline side-chain polymer. Polym. J. 25, 347 (1993).CrossRefGoogle Scholar