Hostname: page-component-586b7cd67f-dsjbd Total loading time: 0 Render date: 2024-11-29T07:39:35.170Z Has data issue: false hasContentIssue false
  • English
  • Français

Performance of μ-Si:H Solar Cells with Amorphous P-Layer

Published online by Cambridge University Press:  10 February 2011

Frank Siebke ,
Shigeo Yata ,
Yoshihiro Hishikawa  and
Makoto Tanaka
Frank Siebke
Affiliation:
New Materials Research Center, SANYO Electric Co., Ltd, 1-18-13 Hashiridani, Hirakata, Osaka 573, Japan
Shigeo Yata
Affiliation:
New Materials Research Center, SANYO Electric Co., Ltd, 1-18-13 Hashiridani, Hirakata, Osaka 573, Japan
Yoshihiro Hishikawa
Affiliation:
New Materials Research Center, SANYO Electric Co., Ltd, 1-18-13 Hashiridani, Hirakata, Osaka 573, Japan
Makoto Tanaka
Affiliation:
New Materials Research Center, SANYO Electric Co., Ltd, 1-18-13 Hashiridani, Hirakata, Osaka 573, Japan
Get access

Abstract

We investigated p-i-n solar cells with microcrystalline absorber but amorphous contact layers. Fill factor and open circuit voltage depend sensitively on the p/i interface. Using an optimized design of the p/i interface, cells with fill factors up to 65% and open circuit voltages of 0.45 V were deposited on amorphous p-layers. They are comparable to cells on micro- crystalline p-layers. A further increase of the open circuit voltage was achieved by variation of the p/i interface treatment but up to now it was accompanied by a decrease of the fill factor. We attribute this effect to a thin undoped amorphous layer at the p/i interface. Under non-optimized deposition conditions an amorphous instead of a microcrystalline silicon layer is grown at the p/i interface which can be detected by Raman measurements on cell structures. While the proper design of the p/i interface is crucial for the cell performance we did not observe significant differences between cells with amorphous and microcrystalline n-layers. The results reveal that the open circuit voltage is limited by the bulk properties of the undoped microcrystalline silicon.

Type
Research Article
Information
MRS Online Proceedings Library (OPL) , Volume 507: Symposium A – Amorphous & Microcrystalline Silicon Technology 1998 , 1998 , 517
Copyright
Copyright © Materials Research Society 1998

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1 Yoshida, T., Maruyama, K., Nabeta, O., Ichikawa, Y., Sakai, H. and Uchida, Y., Proc. 19th IEEE Photovoltaic Specialist Conf., p. 1,095(1993).Google Scholar
2 Nakabeppu, F., Ishimura, T., Kumagai, K. and Fukui, K., Mater. Res. Soc. Symp. Proc. 164, p. 389 (1990).Google Scholar
3 Meier, J., Torres, P., Platz, R., Dubail, S., Kroll, U., Selvan, J. A. Anna, Vaucher, N. Pellaton, Hof, Ch., Fischer, D., Keppner, H., Shah, A., Ufert, K.-D., Giannoules, P. and Koehler, J., Mater. Res. Soc. Symp. Proc. 420, p. 3 (1996).Google Scholar
4 Flhickiger, R., Meier, J., Keppner, H., M. Gotz and Shah, A., Twenty Third IEEE Photovoltaic Specialist Conference, p. 839 (1993).Google Scholar
5 Dalal, V. L., Kaushal, S., Ping, E. X., Xu, J., R. Knox and Han, K., Mat. Res. Soc. Symp. Proc. 377, p. 137 (1995).Google Scholar
6 Hishikawa, Y., Nakamura, N., Tsuda, S., Nakano, S., Y. Kishi and Kuwano, Y., Jpn. J. Appl. Phys. 30, p. 1008 (1991).Google Scholar
7 Vanecek, M., Kocke, J., Stuchlik, J., Kozizek, Z., Stika, O. and Triska, A., Sol. Energy Mater. 8, p. 411 (1983).Google Scholar
8 Luysberg, M., Hapke, P., Carius, R. and Finger, F., Philos. Mag. A 75, p. 31 (1997).Google Scholar
9 Tzolov, M., Finger, F., Carius, R. and Hapke, P., J. Appl. Phys. 81, p. 7376 (1997).Google Scholar
10 Zimmer, J., Stiebig, H. and Wagner, H., this conference.Google Scholar
11 Siebke, F., Yata, S.. Hishikawa, Y. and Tanaka, M., Jap. J. Appl. Phys. 37 in print.Google Scholar